2000 Winnebago Adventurer recalls & complaints

Component: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Summary: VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE BUCKLE ASSEMBLIES.
Notes: OWNER NOTIFICATION BEGAN OCTOBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939 OR AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Summary: VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. OWNER NOTIFICATION BEGAN MAY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 1-219-266-8330 OR WINNEBAGO AT 1-641-585-6939.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EQUIPMENT
Summary: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: VEHICLE DESCRIPTION: MOTOR HOMES. THE COPPER LINE SUPPLYING LIQUID PROPANE GAS (LPG) TO THE FURNACE MAY HAVE BEEN IMPROPERLY CLAMPED, WHICH COULD CAUSE THE LINE TO COME IN CONTACT WITH A METAL FLANGE.
Consequence: IF THIS HAPPENS, THE COPPER LINE COULD BE DAMAGED AND COULD DEVELOP A LEAK WHICH HAS THE POTENTIAL TO IGNITE.
Remedy: DEALERS WILL RE-ROUTE THE LPG LINE. OWNER NOTIFICATION BEGAN APRIL 12, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP
Summary: CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.
Notes: WINNEBAGO RECALL NO. 88. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

06/06/2011 · Brakes
TL*THE CONTACT OWNS A 2000 WINNEBAGO ADVENTURER. WHILE DRIVING APPROXIMATELY 5 MPH WITH THE GEAR IN REVERSE, THE BRAKE PEDAL DROPPED TO THE FLOOR BOARD. THE CONTACT EXIT THE VEHICLE AND NOTICED FLUID LEAKING FROM THE BRAKE LINE. THE CONTACT STATED THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INSPECTED THE BRAKE LINE AND NOTI…

11/06/2009 · Lights
THE HEADLIGHT ASSEMBLY MOUNTING BRACKET GLUED TO THE FRONT FIBERGLASS FACIA BECAME UN-ATTACHED. THE ASSEMBLY DROPPED OUT OF ITS POSITION AND THE STEEL BRACKET WAS ABOUT TO FALL OFF. THE ONLY ATTACHMENT TO THE HEADLIGHT ASSEMBLY WAS THE ELECTRICAL WIRE CONNECTED TO THE HEADLAMP. MY IMMEDIATE CONCERN WAS THE STEEL BRACKET WOULD FALL TO THE PAVEMENT POTENTIAL…

02/04/2008 · Vehicle Speed Control
WE HAVE HAD PROBLEMS WITH OUR CRUISE CONTROL DISENGAGING AND SPEEDOMETER NOT WORKING SINCE OUR RV WAS NEW. WE RECEIVED A RECALL FROM FORD (05S28) IN SEPTEMBER 2007 AND I CALLED AGAIN TODAY, FEBRUARY 4 AND THEY STILL DO NOT HAVE THE PARTS TO REPAIR THE RECALL. *TR

06/11/2007 · Latches / locks
RE: A&E AWNING M 8500 BY DOMETIC, PO BOX 490, ELKHART, IN 46515 ON 2000 WINNEBAGO ADVENTURE MOTOR HOME. SERIOUS DESIGN DEFECT CAUSED CATASTROPHIC FAILURE WHICH COULD HAVE RESULTED IN SERIOUS INJURY OR LOSS OF LIFE. SAME DESIGN DEFECT CAUSED A FAILURE IN APRIL 2003 ,WHICH WAS NOT AS SERIOUS AND ONLY REQUIRED THE REPLACEMENT OF THE AWNING FABRIC AND LOCKI…

02/05/2007 · Brakes
TL* - THE CONTACT OWNS A 2000 WINNEBAGO ADVENTURER WPG32V. THE CONTACT STATED THAT THE MEDAL BRACKETS ON THE FRONT GRILL BROKE OFF, AND HE REPAIRED THEM HIMSELF DUE TO THE COST. THE CONTACT STATED THAT IN 2005 THE FIBERGLAS SIDING BEGAN BUBBLING, AND THE ADHESIVE WAS NOT SECURING THE SIDING AROUND WINDOWS AND JUST LIFTED IT AWAY FROM THE WINNEBAGO.…

07/14/2006 · Engine
WE WERE DRIVING DOWN THE ROAD IN OUR 2000 WINNEBAGO MOTOR HOME WITH FORD V-10 TRITON ENGINE, WHEN A SPARK PLUG BLEW OUT. WE HAD TO BE TOWED BACK TO THE DEALER, WHO IS REFUSING ANY RESPONSIBILITY TO REPAIR OUR ENGINE. OUR MOTOR HOME ONLY HAS 14,000 MILES ON IT. THE EXTENDED WARRANTY COMPANY IS SAYING THAT THIS IS NOT A COVERED REPAIR. *JB

05/30/2006 · Fuel system
CONSUMER CONCERNED ABOUT THE 2000 WINNEBAGO ADVENTURER CHASSIS BOLT WHICH WAS CONTACTING THE LP GAS LINE LEADING FROM THE LP TANK TO THE FRONT OF THE COACH. *TS THERE WAS WEAR ON THE LP LINE WHERE THE CHASSIS BOLT IS LOCATED. THE CONSUMER IS CONCERNED THAT THE LINE MAY RUPTURE. *NM UPDATED 06/12/06. *JB

09/27/2004 · Body / structure
THE ROOF OF THE MOTOR HOME LIFTED OFF THE J RAIL ON EITHER SIDE OF THE MOTOR HOME. CONSUMER CONTACTED THE WINNEBAGO, AND WAS TOLD THAT THEY WERE AWARE OF THE DEFECT THAT CAUSED THE ROOF TO LIFT IN A SEVERE CROSS WIND, BUT WERE NOT WILLING TO REPAIR THE DEFECT.*AK