1995 BMW 740il recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.
What could happen: THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
The fix: FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 10E021000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-877-634-0063.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:LINKAGES:DRAG:LINK:CONNECTION
Summary: FCP GROTON IS RECALLING CERTAIN STEERING CENTER DRAG LINKS, P/N 32 21 1 096 057, SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AS REPLACEMENT EQUIPMENT FOR MODEL YEAR 1995 THROUGH 2001 BMW 740I, 740IL, AND 750IL PASSENGER VEHICLES. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.
Consequence: THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
Remedy: FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FCP GROTON STEERING CENTER DRAG LINKS BEARING P/N 32 21 1 096 057 SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON ANY VEHICLES MANUFACTURED BY BMW. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. THE LOWER SUSPENSION ARM MOUNTING EYE ON THE RIGHT SIDE REAR AXLE HUB CARRIER WAS PRODUCED WITH A CASTING FLAW.
What could happen: IT IS POSSIBLE THAT THE RIGHT SIDE REAR AXLE CARRIER EYE COULD CRACK AND BREAK WHILE DRIVING CAUSING A LOSS OF CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL INSPECT THE VEHICLES FOR A CASTING FLAW IN THE RIGHT SIDE REAR AXLE CARRIER AND IF FOUND, REPLACE THE CARRIER.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 95V192000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:REAR
Summary: THE LOWER SUSPENSION ARM MOUNTING EYE ON THE RIGHT SIDE REAR AXLE HUB CARRIER WAS PRODUCED WITH A CASTING FLAW.
Consequence: IT IS POSSIBLE THAT THE RIGHT SIDE REAR AXLE CARRIER EYE COULD CRACK AND BREAK WHILE DRIVING CAUSING A LOSS OF CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR A CASTING FLAW IN THE RIGHT SIDE REAR AXLE CARRIER AND IF FOUND, REPLACE THE CARRIER.
Notes: SYSTEM: SUSPENSION; SINGLE AXLE; REAR. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. FUEL SEEPAGE CAN OCCUR BETWEEN A HOSE AND THE METAL FUEL LINE ON EITHER END OF THE HOSE RESULTING IN FUEL ODOR.
What could happen: FUEL LEAKAGE COULD POTENTIALLY RESULT IN A VEHICLE FIRE.
The fix: DEALERS WILL REPLACE THE TWO FUEL HOSES, FOUR METAL FUEL LINES AND ASSOCIATED CLAMPS.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 95V238000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: FUEL SEEPAGE CAN OCCUR BETWEEN A HOSE AND THE METAL FUEL LINE ON EITHER END OF THE HOSE RESULTING IN FUEL ODOR.
Consequence: FUEL LEAKAGE COULD POTENTIALLY RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE TWO FUEL HOSES, FOUR METAL FUEL LINES AND ASSOCIATED CLAMPS.
Notes: SYSTEM: FUEL; FUEL LINES; HOSES; NON-METALLIC. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
What could happen: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
The fix: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V140000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1995 BMW 740il owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (4), Visibility (wipers / glass) (3), Electrical system (1), Vehicle Speed Control (1), Steering (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/19/2013 · Electrical system
I WAS DRIVING TO WORK AND WAS PASSING A TRUCK IN FRONT OF ME AND HEARD A LOUD POP. I THOUGHT MY WINDSHIELD HAD BEEN HIT BY SOMETHING UNTIL I SAW THAT THERE WAS NO DAMAGE, SO I KEPT DRIVING. MY CAR BEGAN TO OVERHEAT SO I SLOWED DOWN. WHEN I GOT TO WORK I LOOKED AT MY CAR AND SAW THAT THE HOOD HAD AN ALMOST HOLE IN IT SO I LOOKED UNDER THE HOOD AND FOUND MY B…
06/19/2013 · Steering
WHEN I GET INTO MY CAR THE STEERING WHEEL IS LOCKED AND I CAN'T GET IT UNLOCKED UNLESS I TURN ON AND OFF MY CAUTION LIGHTS OR MOVE THE BUTTON BACK AND FORTH ON THE CONSOLE THAT HAS AN A ON ONE END AND A M ON THE OTHER. AS SOON AS I GET OUT OF THE CAR IT LOCKS AND WON'T MOVE UNLESS I DO THAT AND I HAVEN'T FIGURED OUT WHY THIS IS HAPPENING. IT JUST STARTED W…
07/20/2005 · Engine
RADIATOR FAN EXPLODED WHILE DRIVING ON FREEWAY. PIECES OF FAN FLEW THROUGHOUT ENGINE BAY (HOOD DENTED UPWARDS 2 INCHES) BROKEN PIECES OF FAN LODGED UNDER THROTTLE MECHANISM - WEDGED THROTTLE WIDE OPEN. CAR CONTINUED TO ACCELLERATE EVEN UNDER FULL BRAKING (TO LIMIT OF MY STRENGTH). HAD TO SHUT ENGINE OFF AND STEER OFF FREEWAY WITHOUT POWER STEERING OR BR…
11/24/2003 · Fuel system
THE VEHICLE WAS INCLUDED IN RECALL 95V238000 FOR FUEL HOSE LEAKAGE. THE RECALL WAS PERFORMED IN 1996 BUT FUEL BEGAN TO LEAK AGAIN. THE CONSUMER HAS REPLACED THE HOSES TWICE SINCE THE RECALL AND THEY ARE LEAKING AGAIN *AK *NLM
04/14/2003 · Engine
THE ENGINE COLLAPSED WITHOUT WARNING. THE DEALER DIAGNOSED THE PROBLEM AS BROKE PISTON, WHICH CAUSED THE ENGINE ROD AND CYLINDER TO FAIL. *JB
01/23/2003 · Visibility (wipers / glass)
AMPUTATION OF FINGER IN BMW ELECTRIC WINDOW
05/27/2002 · Engine
CLOGGED VENT TUBE AND EXPANSION TANK CAUSED EXCESS VACUUM WHICH COLLAPSED FUEL TANK. TANK CREASED AS A RESULT AND LEAKING GAS ALONG CREASE.*AK
02/06/2002 · Seats · fire
AFTER GETTING OUT OF VEHICLE AND RETURNING 35 MINUTES LATER, NOTICED WINDOW WAS SMOKY. AFTER OPENING DOOR, CONSUMER NOTICED THAT HEATED SEATS MELTED. FIRE DEPARTMENT WAS CONTACTED, AND PUT FIRE OUT. *AK *YH