1996 BMW 740il recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.
What could happen: THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
The fix: FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 10E021000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-877-634-0063.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:LINKAGES:DRAG:LINK:CONNECTION
Summary: FCP GROTON IS RECALLING CERTAIN STEERING CENTER DRAG LINKS, P/N 32 21 1 096 057, SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AS REPLACEMENT EQUIPMENT FOR MODEL YEAR 1995 THROUGH 2001 BMW 740I, 740IL, AND 750IL PASSENGER VEHICLES. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.
Consequence: THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
Remedy: FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FCP GROTON STEERING CENTER DRAG LINKS BEARING P/N 32 21 1 096 057 SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON ANY VEHICLES MANUFACTURED BY BMW. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
What could happen: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
The fix: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 740IL.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V140000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (3), Gasoline (3), Engine (3), Vehicle Speed Control (3), Latches / locks (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
03/05/2014 · Fuel system
THE GAS TANK STARTED TO MAKE POPPING NOISES AND THUMPING SOUNDS. THEN WHEN I REALIZED SOMETHING IS WRONG WHEN THE GAS GAUGE STARTED READING 1/4 TANK WHEN IT WAS EMPTY, STRANGELY WHEN I WAS FILLING UP WITH GAS THE CAP WAS HARD TO REMOVE AND AS SOON AS I REMOVED THE CAP AIR WAS RUSHING IN. I RAN OUT OF GAS ON THE INTERSTATE WITHOUT ANY WARNING MANAGED TO GET…
07/24/2008 · Vehicle Speed Control
ANYTIME YOU ARE ACCELERATING THE THROTTLE CABLE WILL EITHER GET STUCK OR IF YOU LET OFF THE GAS PEDAL ITS WILL CONTINUE TO ACCELERATE. THIS CAN BE VERY DANGEROUS ESPECIALLY UPON ENTERING THE HIGHWAY. THIS OCCURRED PRETTY REGULARLY UNTIL WE HAD THE THROTTLE CABLE REPLACED. *TR
05/14/2008 · Engine
TL*THE CONTACT OWNS A 1996 BMW 740IL. WHILE PARKING THE VEHICLE, THE CONTACT ATTEMPTED TO SHUT OFF THE ENGINE AND EXIT THE VEHICLE. AS SHE TURNED THE KEY AND REMOVED IT FROM THE IGNITION, THE ENGINE REMAINED RUNNING AND WOULD NOT SHUT OFF. SHE HAD TO REMOVE THE ENGINE FUSES FROM UNDER THE HOOD AND DISCONNECT THE BATTERY IN ORDER TO SHUT OFF THE ENGINE.…
03/30/2005 · Vehicle Speed Control
VEHICLE IS EXPERIENCING SUDDEN ACCELERATION. AS SOON AS THE VEHICLE IS STARTED, THE RPM'S WILL REV UP TO 3500 RPMS PREVENTING THE DRIVER FROM PUTTING THE VEHICLE IN GEAR WITHOUT A POSSIBLE CRASH. DRIVER WOULD APPLY THE BRAKES BUT THE VEHICLE WILL CONTINUE TO SURGE. PROVIDE FURTHER DETAIL. DEFECTIVE PARTS REPLACED. CAR WENT BY ITSELF TO 90 MPH ON THE INTE…
04/29/2002 · Engine
THIS PROBLEM W/ RADIATOR IS VERY COMMON W/ THIS VEHICLE AND MANUFACTURER REFUSES ANY RESPONSIBILITY. *AK
10/10/2001 · Fuel system
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
08/22/2001 · Fuel system
GAS TANK IMPLODED SUCKING ITSELF IN AND CAUSING GAS TO LEAK AND SPILL. TANK WAS REPLACED IN SEPTEMBER OF 2000. HOWEVER, PROBLEM HAS BEEN ONGOING SINCE THEN. ALSO, THERE ARE POPPING NOISES COMING FROM TANK AREA, WHICH MEANS THAT GAS IN TANK IS NOT PROPERLY VENTING,CAUSING A BUILD UP. TECHNICIANS HAVE HEARD THE NOISE, BUT ARE UNABLE TO RECTIFY IT WHEN…
12/19/2000 · Latches / locks
HOOD CAME CRASHING UP AGAINST WINDSHIELD WHILE DRIVING ON FREEEWAY. THIS COULD HAVE CAUSED A CRASH DEALER FOUND THAT THE SAFETY HOLD DOWN PIN ON THE LEFT SIDE HOOD LOCK WAS MISSING, DEALER REPLACED THE HOOD LOCK ASSEMBLY. *AK *SLC