2003 Chevrolet Cavalier recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
What could happen: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
The fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 CAVALIER.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 08E063000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-523-2492.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING
Summary: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes: THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOU…
What could happen: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
The fix: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 CAVALIER.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 04V524000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:TURN SIGNAL
Summary: ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 04083. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2003 Chevrolet Cavalier owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (389), Gasoline (343), Electrical system (115), Lights (60), Engine (49).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/07/2025 · Electrical system
There is a recall on the vehicle I need to get fixed.
05/02/2021 · Steering
THE STEERING WHEEL IS LOOSE. PINS ON TILT MECHANISM ARE GONE. DON'T KNOW WHEN IT FELL OUT. NOTICED WHEN CLEANING CAR WHEN I TILTED THE STEERING WHEEL UP.
05/02/2021 · Steering
MY CAR HAS THE SAME PROBLEM WITH THE INSTRUMENT CLUSTER THAT WAS RECALLED FOR OTHER GM VEHICLES. THE FUEL LEVEL GAUGE, TEMPERATURE GAUGE, RPM, SPEEDOMETER.... NONE OF MY GAUGES WORK. THEY GAVE THE WRONG READINGS, THE HAND WOULDN'T RETURN TO THEIR STARTING POSITIONS, THEN THE HANDS WENT LOWER THAN THEIR STARTING POSITIONS TO THE POINT THEY ALL DIDN'T WORK AN…
04/05/2018 · Unknown Or Other
TAKATA RECALL
01/28/2018 · Electrical system
CLUSTER OF DASHBOARD INDICATORS (SPEEDOMETER, GAS GUAGE , ENGINE TEMP, RPM) ALL ARE NOT WORKING NOW. THEY WERE GOING OFF AND ON AT TIMES WHEN DRIVING BUT NOW NOTHING WORKS...MY MECHANIC INFORMS ME THIS IS A COMMON PROBLEM WITH THIS MAKE AND MODEL. NO RECALL FOUND. VERY DANGEROUS TO DRIVE WHY WASN'T THIS COMMON PROBLEM LISTED AS A RECALL WHEN MANY HAVE C…
08/31/2016 · Electronic Stability Control (esc)
I WAS ONE BLOCK FROM HOME AND MY CAR STALLED IT WOULDN'T START BACK UP. I FOUND MY SELF AT THE INTERSECTION. THE MECHANIC SAID IT IS A BAD FUEL PUMP. THE CAR ONLY HAS 60,000 MILES. THIS HAPPENED ABOUT THIS TIME LAST YEAR . ALSO LAST YEAR MY GAUGE TO MY ENGINE TEMPERATURE WENT OUT OF CONTROL. I CAN'T TELL THE ENGINE TEMP. ANYMORE.
06/26/2016 · Suspension
MY 2003 CHEVROLET CAVALIER RECENTLY BEGAN TO MAKE A CLUNKING NOISE, WHICH CAN ALSO BE FELT, IN THE FRONT END. WHEN I PUT IT UP ON A LIFT, I NOTICED THAT THE SUB-FRAME WAS RUSTING (DETERIORATING). I KNOW IT IS 13 YEARS OLD, BUT MY PARENTS OWNED A 1989 CAVALIER Z24 FOR 20 YEARS, AND THEY DIDN'T HAVE ANY PROBLEMS WITH ITS FRAME. I'VE READ THAT OTHER PEOPLE…
05/06/2016 · Electrical system
"CHECK ENGINE" LIGHT KEEPS COMING BACK ON FOR THE SAME ISSUE, SUPPOSEDLY THE "AIR INTAKE TEMP SENSOR, REPLACED THAT ONE AND SEVERAL SENSORS REPEATEDLY, HAD THE COMPLETE WIRING HARNESS CONNECTIONS CHECKED AND CLEANED, EVEN REPLACED MY ECM AND BCM [NEITHER OF WHICH WAS CHEAP], AND STILL HAS "CHECK ENGINE" LIGHT, EVEN AFTER BEING "CLEARED" OVER AND OVER AGAIN…