2016 Chevrolet Cruze Limited recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. The vehicles may leak gasoline following a rear-impact crash and a rollover. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
What could happen: A fuel leak, in the presence of an ignition source, increases the risk of a fire.
The fix: GM will notify owners, and dealers will install a lock-ring on the fuel tank that will shield the fuel tank vapor pressure sensor from damage in a rear-impact crash, free of charge. The recall began June 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18159.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE LIMITED.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 18V304000 (manufacturer code 18159).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Cruze LS vehicles, equipped with a gasoline engine and a tire inflator kit instead of a spare tire. The vehicles may leak gasoline following a rear-impact crash and a rollover. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence: A fuel leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: GM will notify owners, and dealers will install a lock-ring on the fuel tank that will shield the fuel tank vapor pressure sensor from damage in a rear-impact crash, free of charge. The recall began June 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18159.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Seats
What's wrong, in plain English: Seat frames, adjusters or child-seat anchors. A bracket used in the driver or front passenger seat-back recliner mechanism may have been incorrectly welded to the seat-back frame, as a result, in the event of a crash, the head-restraints may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints."
What could happen: In a crash, the seat-backs for the front seats may break, increasing the risk of injury to the occupants.
The fix: GM will notify owners, and dealers will inspect the front passenger seats, replacing any with seat-back frames that are incorrectly welded, free of charge. The recall began on February 28, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17035.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE LIMITED.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 17V057000 (manufacturer code 17035).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
Summary: General Motors LLC (GM) is recalling certain 2016-2017 Chevrolet Cruze vehicles. A bracket used in the driver or front passenger seat-back recliner mechanism may have been incorrectly welded to the seat-back frame, as a result, in the event of a crash, the head-restraints may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints."
Consequence: In a crash, the seat-backs for the front seats may break, increasing the risk of injury to the occupants.
Remedy: GM will notify owners, and dealers will inspect the front passenger seats, replacing any with seat-back frames that are incorrectly welded, free of charge. The recall began on February 28, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17035.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. The headlight assemblies are not marked with a three-digit identifier code used to properly aim the headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
What could happen: Without the identification code, the headlights may be improperly aimed during service, reducing nighttime visibility and increasing the risk of a crash.
The fix: GM will mail owners instructions and adhesive labels, with the correct code, to install on their headlight assemblies. Owners may also bring the vehicle to a GM dealership for any assistance with applying the label, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet Customer Service D…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE LIMITED.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 16V498000 (manufacturer code 50190).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: General Motors LLC (GM) is recalling certain model year 2016 Cruze vehicles manufactured November 5, 2015, to May 26, 2016. The headlight assemblies are not marked with a three-digit identifier code used to properly aim the headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
Consequence: Without the identification code, the headlights may be improperly aimed during service, reducing nighttime visibility and increasing the risk of a crash.
Remedy: GM will mail owners instructions and adhesive labels, with the correct code, to install on their headlight assemblies. Owners may also bring the vehicle to a GM dealership for any assistance with applying the label, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet Customer Service Department at 1-800-222-1020. GM's number for this recall is 50190.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection…
What could happen: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
The fix: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE LIMITED.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 16V502000 (manufacturer code 50490 and 50491).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION
Summary: General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2016 Chevrolet Cruze Limited owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (104), Electrical system (57), Unknown Or Other (40), Fuel system (35), Transmission / drivetrain (31).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/15/2025 · Unknown Or Other
My husband was driving and noticed smoke coming from the engine so we pulled over and he lifted the hood and when he did we clearly saw a part of the Bosch manifold absolute pressure map sensor had come off and appeared to have melted off. I have taken it to a mechanic and have photos to show the exact parts.
03/05/2025 · Engine
The contact owns a 2016 Chevrolet Cruze. The contact stated that while driving at various speeds, an abnormal burning odor was coming from the vehicle. The contact stated that while driving 40 MPH, the temperature gauge indicated that the engine was hot(H). The contact pulled over, added water to the coolant reservoir, and the vehicle returned to normal ope…
12/26/2024 · Electrical system
My tire pressure sensor keeps coming on even after I had it worked on. 3 of them shows the pressure level but one shows 2 lines but no pressure level but there’s air in the tire. The other problem I’m having is the check engine light is on. Please advise if any issues are recalls or do I need to take my car to a service center. Thank you
11/22/2024 · Engine
The turbo has gone out twice, it was replaced under an extended warranty policy and it has gone out again and is out of warranty, also the plastic intake manifold has gone bad again. also there is a plastic piece that comes off the engine and distributes coolant to the heater core etc...it has gone bad as well and is common on all 1.4 turbos..
10/06/2024 · Fuel system
I was driving the car, stopped at a light took my foot off the brake started to move and the car completely shut off. No warning lights went on. I had to start the car again. I took the car to a local dealership to be looked at. They pulled the codes, nothing showed up. I did an internet search for a possible cause, sent my search results to the dealership…
08/27/2024 · Wheels / tires
Purchased a 2016 Chevrolet Cruze on [XXX]. [XXX]. As of July 26th I paid $862 on repairs for the car to be smoking this morning on my way to work [XXX]. In total I’ve spent Almost or close to $2,000 in car repairs. This purchase was for my 17 year old daughter as a graduation present and for college. She was driving and car started to run hot and cut off i…
08/14/2024 · Wheels / tires
I HAVE A 2016 CHEVROLET CRUZE AND THE TURBOCHARGER INTERCOOLER HOSE BASICALLY BROKE FROM WHERE THE END OF THE HOSE STARTS AND A LITTLE BIT DOWN IN THE MIDDLE AREA OF THE END PART OF THE HOSE. AND THIS CAUSED MY ENGINE'S POWER TO BE REDUCED INMENSLY. TO THE POINT THAT I HAD MY FOOT PRESSING ALL THE WAY DOWN ON THE ACCELERATOR AND IT COULD NOT GO ANY FURTHER…
07/18/2024 · Engine
Defouw Chevrolet was negligent in performing the proper repairs per a GM service bulletin and special coverage. They refused to provide service, falsely claimed that I refused diagnostic, misdiagnosed the vehicle, replaced the wrong part, and were extremely rude and misogynistic. Additionally, they claim the issues were pre-existing while lacking any eviden…