2016 Chevrolet Cruze recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. The vehicles may leak gasoline following a rear-impact crash and a rollover. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
What could happen: A fuel leak, in the presence of an ignition source, increases the risk of a fire.
The fix: GM will notify owners, and dealers will install a lock-ring on the fuel tank that will shield the fuel tank vapor pressure sensor from damage in a rear-impact crash, free of charge. The recall began June 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18159.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 18V304000 (manufacturer code 18159).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Cruze LS vehicles, equipped with a gasoline engine and a tire inflator kit instead of a spare tire. The vehicles may leak gasoline following a rear-impact crash and a rollover. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
Consequence: A fuel leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: GM will notify owners, and dealers will install a lock-ring on the fuel tank that will shield the fuel tank vapor pressure sensor from damage in a rear-impact crash, free of charge. The recall began June 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18159.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Seats
What's wrong, in plain English: Seat frames, adjusters or child-seat anchors. A bracket used in the driver or front passenger seat-back recliner mechanism may have been incorrectly welded to the seat-back frame, as a result, in the event of a crash, the head-restraints may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints."
What could happen: In a crash, the seat-backs for the front seats may break, increasing the risk of injury to the occupants.
The fix: GM will notify owners, and dealers will inspect the front passenger seats, replacing any with seat-back frames that are incorrectly welded, free of charge. The recall began on February 28, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17035.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 17V057000 (manufacturer code 17035).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
Summary: General Motors LLC (GM) is recalling certain 2016-2017 Chevrolet Cruze vehicles. A bracket used in the driver or front passenger seat-back recliner mechanism may have been incorrectly welded to the seat-back frame, as a result, in the event of a crash, the head-restraints may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints."
Consequence: In a crash, the seat-backs for the front seats may break, increasing the risk of injury to the occupants.
Remedy: GM will notify owners, and dealers will inspect the front passenger seats, replacing any with seat-back frames that are incorrectly welded, free of charge. The recall began on February 28, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17035.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. The headlight assemblies are not marked with a three-digit identifier code used to properly aim the headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
What could happen: Without the identification code, the headlights may be improperly aimed during service, reducing nighttime visibility and increasing the risk of a crash.
The fix: GM will mail owners instructions and adhesive labels, with the correct code, to install on their headlight assemblies. Owners may also bring the vehicle to a GM dealership for any assistance with applying the label, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet Customer Service D…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 16V498000 (manufacturer code 50190).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: General Motors LLC (GM) is recalling certain model year 2016 Cruze vehicles manufactured November 5, 2015, to May 26, 2016. The headlight assemblies are not marked with a three-digit identifier code used to properly aim the headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
Consequence: Without the identification code, the headlights may be improperly aimed during service, reducing nighttime visibility and increasing the risk of a crash.
Remedy: GM will mail owners instructions and adhesive labels, with the correct code, to install on their headlight assemblies. Owners may also bring the vehicle to a GM dealership for any assistance with applying the label, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet Customer Service Department at 1-800-222-1020. GM's number for this recall is 50190.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection…
What could happen: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
The fix: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 CRUZE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 16V502000 (manufacturer code 50490 and 50491).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION
Summary: General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2016 Chevrolet Cruze owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (108), Electrical system (59), Unknown Or Other (43), Fuel system (38), Transmission / drivetrain (31).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/17/2026 · Electrical system
I am filing this complaint due to repeated mechanical and safety problems with my 2016 Chevrolet Cruze. The vehicle has had ongoing acceleration problems, including times when it would not accelerate properly even with the A/C on its lowest setting. The turbocharger has needed to be replaced multiple times, yet acceleration problems have continued. I have…
08/27/2026 · Brakes
car has been overheating run while i take the keys out doors will lock with keys in the ignition lots of lights will come on car will slow way down constantly adding antifreeze in it heat and air will stop working i have had trouble ever since i bought this a year ago
08/24/2026 · Engine
Manufacturer: General Motors / Chevrolet Vehicle: 2016 Chevrolet Cruze LT (VIN: [XXX]) Corporate Case Number: XXX Nature of Dispute: Premature mechanical failure of a major drivetrain assembly and administrative bad faith. Factual Timeline: Initial Failure & Prior Liability: At 51,490 miles, the vehicle suffered a mechanical failure of the turbocharger asse…
06/22/2026 · Unknown Or Other
After 3 years of having this car it’s overheating each summer requiring the coolant system, hoses, thermostat, and water pump to be replaced each summer. As well as major oil leaking after full tune ups.
06/09/2026 · Unknown Or Other
Coolant system and engine fan
05/09/2026 · Engine
My engine needed oil I checked the dip stick added the oil the next day my engine started leaking and over heating come to find out there’s a pcv issue the valve cover gasket along with multiple other seals need replaced I was unaware of anything wrong no indication of over heating I just smelled the heat and was able to see after popping the hood the radia…
04/15/2026 · Steering
While driving, I went to make a right turn and the power steering went out making the turn very difficult using manual muscle to complete the turn. Fortunately, it was in a parking lot. After the ignition was turned off for about 45 minutes, I turned it back on and the steering functioned normally. However, I am very concerned if this problem would again…
04/13/2026 · Unknown Or Other
There has been no accident to report. My check engine light comes on periodically and will remain on for a lengthy time. It is the light that looks like a water spigot. When I have it checked they say it’s either the “Turbo” or “Air Filter” . I can. It get a clear answer as to what it is and why it comes on or how to fix the problem. My car is actually a 20…