2022 Chevrolet Malibu recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. The front impact bar, a structural portion of the vehicle frame, may not be properly welded to the front frame rail.
What could happen: An improperly welded front impact bar may result in the front crash sensors not performing correctly, increasing the risk of injury in a crash.
The fix: Dealers will inspect the right-hand and left-hand side of the vehicle's motor rail for an incomplete weld. If the condition is found, the vehicle will be repurchased by GM. Owner notification letters were mailed January 20, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 MALIBU.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 22V923000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:FRAME AND MEMBERS
Summary: General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Malibu vehicles. The front impact bar, a structural portion of the vehicle frame, may not be properly welded to the front frame rail.
Consequence: An improperly welded front impact bar may result in the front crash sensors not performing correctly, increasing the risk of injury in a crash.
Remedy: Dealers will inspect the right-hand and left-hand side of the vehicle's motor rail for an incomplete weld. If the condition is found, the vehicle will be repurchased by GM. Owner notification letters were mailed January 20, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to www.nhtsa.gov.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Engine (39), Electrical system (33), Unknown Or Other (29), Transmission / drivetrain (23), Fuel system (10).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/28/2026 · Electrical system
My Malibu has numerous electrical problems. Often involving the start stop feature. The door locks have locked and unlocked themselves The engine and battery warning light will come on but we don't know why. A metal piece of the front frame broke off and went through the condenser. I had to have the car towed causing more damage to the hood. I cannot…
09/21/2026 · Seats
The contact owns a 2022 Chevrolet Malibu. The contact stated that while the vehicle was parked, while adjusting the front driver's seat, the seat adjuster failed to operate as intended. The front driver's seat failed to move backwards. The contact stated that it was a known failure with the vehicle. The manufacturer was contacted by phone and made aware of…
09/03/2026 · Fuel system
Driving along the highway the CEL light came on followed by reduced engine power warning. Vehicle abruptly slowed down to 35mph (limp mode). Were there to be another vehicle behind me, they would have to do emergency braking. My vehicle would not start after pulling over to the shoulder. A tow truck was dispatched, and after diagnosis from the service cente…
09/03/2026 · Brakes
While driving my 2022 Chevrolet Malibu on the freeway, I experienced a loss of braking. This created a serious safety hazard because I was unable to stop the vehicle normally. The vehicle had previously displayed a check-engine warning. I brought the vehicle to the Chevrolet dealer. The dealer is requesting approximately 4,000 for repairs and has refused to…
09/01/2026 · Electrical system
I was driving and all of a sudden all the warning lights start going off on my vehicle’s dashboard and the car jerks back and forth while decelerating. This has happened twice on the highway putting me in danger of crashing or making cars around me crash. On a seperate occasion my brakes failed, causing the car to jerk abruptly in traffic, thankfully I wa…
09/01/2026 · Unknown Or Other
The car started giving warnings on the dash "SHIFT TO PARK" even though the shifter is in park. When it happens you can not shut the car off fully causing the battery to drain, you also can not lock the vehicle. The car only has 19K miles on it and GM refuses to fix because the car is out of the standard warranty period by six months.
08/24/2026 · Engine
The contact owns a 2022 Chevrolet Malibu. The contact stated that while attempting to start the vehicle, the check engine warning light illuminated. An independent mechanic was contacted. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the turbocharger needed to be replaced. The…
07/30/2026 · Engine
The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the message “Engine Power Reduced” was displayed. The failure was a persistent failure. The vehicle was taken to the dealer where it was diagnosed with turbocharger failure. The contact was informed that the turbocharger needed to be replaced. The vehicl…