1995 Chevrolet Monte Carlo recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
5 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
What could happen: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
The fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 MONTE CARLO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 07E021000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. SOME OF THESE VEHICLES HAVE A STRAINED OR SEPARATED WASHER/WIPER SWITCH POWER FEED WIRE.
What could happen: THIS CAN CAUSE THE WINDSHIELD WASHER/WIPER TO WORK INTERMITTENTLY AND COULD ULTIMATELY RESULT IN INOPERATIVE WIPERS. IF THIS WERE TO OCCUR IN A SEVERE WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSPECT AND REPLACE THE OLD DESIGNED WASHER/WIPER SWITCHES WITH A NEWLY DESIGNED SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 MONTE CARLO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 97V017000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
Summary: SOME OF THESE VEHICLES HAVE A STRAINED OR SEPARATED WASHER/WIPER SWITCH POWER FEED WIRE.
Consequence: THIS CAN CAUSE THE WINDSHIELD WASHER/WIPER TO WORK INTERMITTENTLY AND COULD ULTIMATELY RESULT IN INOPERATIVE WIPERS. IF THIS WERE TO OCCUR IN A SEVERE WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE OLD DESIGNED WASHER/WIPER SWITCHES WITH A NEWLY DESIGNED SWITCH.
Notes: OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1997.
NOTES: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. THE CENTER REAR SEAT BELT ANCHOR PLATE EXHIBITS STRESS CRACKS.
What could happen: IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM CAN FRACTURE AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
The fix: DEALERS WILL REPLACE THE CENTER REAR SEAT BELT SYSTEM.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 MONTE CARLO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 97V065000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:ANCHORAGE
Summary: THE CENTER REAR SEAT BELT ANCHOR PLATE EXHIBITS STRESS CRACKS.
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM CAN FRACTURE AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE CENTER REAR SEAT BELT SYSTEM.
Notes: OWNER NOTIFICATION BEGAN MAY 13, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
What could happen: THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
The fix: DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 MONTE CARLO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 01I014000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Summary: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence: THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Remedy: DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes: GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
5. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. A RIGHT-HAND LOWER CONTROL ARM TAPERED BALL JOINT MOUNTING HOLE WAS INCORRECTLY MACHINED. MOVEMENT WITHIN THIS ATTACHMENT CAN ALLOW THE BALL JOINT STUD TO FATIGUE AND FRACTURE.
What could happen: IF THE BALL JOINT FRACTURED WHILE THE VEHICLE WAS IN MOTION, LOSS OF STEERING CONTROL TO THE VEHICLE CAN OCCUR.
The fix: DEALERS WILL REPLACE THE RIGHT-HAND LOWER CONTROL ARM AND BALL JOINT STUD ON ALL INVOLVED VEHICLES.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 MONTE CARLO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 94V230000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: A RIGHT-HAND LOWER CONTROL ARM TAPERED BALL JOINT MOUNTING HOLE WAS INCORRECTLY MACHINED. MOVEMENT WITHIN THIS ATTACHMENT CAN ALLOW THE BALL JOINT STUD TO FATIGUE AND FRACTURE.
Consequence: IF THE BALL JOINT FRACTURED WHILE THE VEHICLE WAS IN MOTION, LOSS OF STEERING CONTROL TO THE VEHICLE CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE RIGHT-HAND LOWER CONTROL ARM AND BALL JOINT STUD ON ALL INVOLVED VEHICLES.
Notes: SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT CHEVROLET AT 1-800-222-1020. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1995 Chevrolet Monte Carlo owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (52), Hydraulic (49), Transmission / drivetrain (29), Engine (21), Suspension (20).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
02/11/2009 · Suspension
TL*THE CONTACT OWNS A 1995 CHEVROLET MONTE CARLO. WHILE DRIVING 40 MPH, THE CONTACT HEARD A LOUD CLUNKING NOISE COMING FROM THE PASSENGER SIDE WHEEL WHEN MAKING A RIGHT TURN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND THE TECHNICIAN STATED THAT THE FRONT BALL JOINTS ON BOTH SIDES OF THE VEHICLE WERE FAILING. THE REPAIR WOULD COST $250. UPON FURTHE…
02/06/2009 · Engine
MY 95 CHEVY MONTE CARLO HAS AN INTAKE PROBLEM. *TR
02/06/2009 · Steering
I'VE HAD A NEW STARTER REPLACED,ALTERNATOR,RADIATOR,POWER STEERING RACK,AND NOW IT HAS AN INTAKE PROBLEM, CAN SOMEONE PLEASE HELP? TIRED OF SPENDING MONEY. CAR SHAKES REALLY HARD WHEN ITS COMES TO A STOP LIKE IT WANTS TO CUT OFF,THEY SAY ITS AN INTAKE PROBLEM. *TR
01/10/2006 · Wheels / tires
WRITER OWNER OF 1995 CHEVROLET MONTE CARLO TIRES DETREADED WHILE DRIVING 40 MPH SUGGEST NHTSA INVESTIGATE AND RECALL TIRES MFRD IN FINLAY OHIO. *TS THE CONSUMER TOOK THE VEHICLE BACK TO THE MECHANIC, AND AFTER SEVERAL TRIES THEY DIAGNOSED THE OTHER THREE TIRES REMAINING AS HAVING BUMPS ON THEM. THE TIRES WERE OVAL SHAPED AND THEREFORE COULD NOT BE BALAN…
09/15/2005 · Vehicle Speed Control
DT: THE CALLER SAID CRUISE CONTROL WILL NOT HOLD TO A CERTAIN SPEED. IT KEPT ACCELERATING EVEN WHEN HITTING THE BRAKE. IT DID NOT HOLD AT ANY SPEED. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED YET. THIS HAPPENED THE LAST TWO TIMES WHEN SHE USED THE CRUISE CONTROL. SHE WILL NOT USE THE CRUISE CONTROL NOW.*AK
07/30/2005 · Suspension
THE CAR WAS SENT TO A LOCAL GARAGE AND THE DEFECT WAS FOUND. THE SERIAL # OF THE CAR IS [XXX]IS THE SAME PROBLEM THAT THE SAME MODEL CAR HAD UNDER RECALL#94V23000 BALL JOINT MOUNT DEFECT. CHEVROLET SAYS THEY WILL NOT FIX THE CAR. THIS WAS FOUND BEFORE ANY ACCIDENTS OR FAILURE HAPPENED. THE CAR IS UNABLE TO PASS INSPECTION DUE TO DEFECT. *JB UPDATED 07/19/2…
02/16/2005 · Suspension · crash
WHILE DRIVING 35 MPH THE FRONT CONTROL ARM AND LOWER BALL JOINTS BROKE. AS A RESULT, THE STEERING AND BRAKES FAILED , AND THE VEHICLE COLLIDED INTO BRICK WALL. UPON IMPACT, THE AIRBAGS DID NOT DEPLOY. NO INJURIES REPORTED. *AK *SC *JB
05/25/2004 · Engine
WHEN COMING TO STOP, THE CRANK SHAFT PULLEY BOLT SNAPPED. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. PLEASE PROVIDE MORE INFORMATION. *JB