1998 Chevrolet Monte Carlo recalls & complaints

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: ENGINE AND ENGINE COOLING
Summary: GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes: GM RECALL NO. 09047. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: STEERING:RACK AND PINION
Summary: CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 03062. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Summary: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence: THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Remedy: DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes: GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.

10/10/2017 · Engine
1998 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO HIS DISAPPROVAL OF EXHAUST MANIFOLD RECALL NOTICE REMOVAL OF THE ENGINE PLASTIC "BEAUTY" COVER. *SMD THE CONSUMER WAS ADVISED THE RECALL INCLUDED REMOVING THE BEAUTY COVER. THE CONSUMER STATED THE RECALL NOTICE DOES SAY THAT THE COVER WILL BE REMOVED, BUT DOES NOT STATE THAT IT WOULDN'T BE RETU…

12/26/2016 · Steering · crash · fire
ON SEPTEMBER 24, 2015, MY WIFE WAS DRIVING OUR MONTE CARLO. UNBEKNOWNST TO HER THE CAR BEGAN SMOKING UNDERNEATH, CAUSING LOSS OF CONTROL WITH NEITHER STEERING NOR BRAKING CAPABILITY. OTHER DRIVERS, NOTICING THE SMOKE, WERE ATTEMPTING TO NOTIFY HER OF THE IMPENDING FIRE. SHE WAS ABLE TO DRIVE ABOUT ANOTHER MILE BEFORE LOSING CONTROL AND CRASHING INTO A TR…

06/29/2016 · Engine · crash · fire
ON SEPTEMBER 24, 2015, MY WIFE WAS DRIVING OUR MONTE CARLO. UNBEKNOWN TO HER THE CAR BEGAN SMOKING UNDERNEATH, CAUSING LOSS OF CONTROL WITH NEITHER STEERING NOR BRAKING CAPABILITY. OTHER DRIVERS, NOTICING THE SMOKE, WERE ATTEMPTING TO NOTIFY HER OF THE IMPENDING FIRE. SHE WAS ABLE TO DRIVE ABOUT ANOTHER MILE BEFORE LOSING CONTROL AND CRASHING INTO A TREE…

06/24/2016 · Engine
TL* THE CONTACT OWNS A 1998 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CO…

12/18/2015 · Engine · fire
TL* THE CONTACT OWNED A 1998 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE NEAR THE ENGINE. THE VEHICLE WAS DESTROYED. NO FURTHER DETAILS WERE AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 05/11/16*BF *TR

10/27/2015 · Airbags · crash
TL* THE CONTACT OWNED A 1998 CHEVROLET MONTE CARLO. WHILE DRIVING 35 MPH, THE VEHICLE CRASHED INTO ANOTHER VEHICLE. THE CONTACT STATED THAT ALL OF THE AIR BAGS DEPLOYED. THE CONTACT WAS INJURED AND REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 198,000…

10/01/2014 · Steering
AT APPROXIMATELY 4 PM I WAS DRIVING WITH THREE OTHER PEOPLE IN MY CAR ON THE STREET IN THE SOUTH SAINT LOUIS COUNTY(RAILROAD CROSSING WEBER RD AND CLOSE TO NEW HAMPSHIRE) AND WE WERE GOING ACROSS THE RAILROAD, WHEN ALL FUNCTIONS OF MY CAR DIED AND THE BRAKES .STEERING. ENGINE , ALL WENT OFF AND I GOT SCARED BUT IN THE HEAT OF THE MOMENT I PULLED MY E…

07/03/2014 · Unknown Or Other · crash
FATAL CAR ACCIDENT ON 270 ON MAY 18TH 2008 4 TEENS KILLED AND 3 OTHERS INJURED. WITH ALL THE GM RECALLS WE ARE CERTAIN THIS WILL END UP BEING PART OF THE RECALL. PLEASE INVESTIGATE. *TR