2018 Chevrolet Silverado 3500 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
6 safety recalls, most serious first
1. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
What could happen: The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.
The fix: GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 17V567000 (manufacturer code 17368, 17375, and 17376).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-988-7267.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:RETRACTOR
Summary: General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Consequence: The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. 6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
What could happen: A short-circuit may damage the engine components and increase the risk of fire.
The fix: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this reca…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 19V328000 (manufacturer code N182206310).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-586-596-1733.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE
Summary: General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
Consequence: A short-circuit may damage the engine components and increase the risk of fire.
Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.
What could happen: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
The fix: GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 19V088000 (manufacturer code N182204190).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.
Consequence: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
Remedy: GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov
4. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. 6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.
What could happen: An electrical short-circuit can increase the risk of a fire.
The fix: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heate…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 21V496000 (manufacturer code 212329840).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-462-8782.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER
Summary: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.
Consequence: An electrical short-circuit can increase the risk of a fire.
Remedy: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
5. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
What could happen: An engine stall increases the risk of a crash.
The fix: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification lett…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 23V047000 (manufacturer code N222368030).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
Summary: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
6. Airbags
What's wrong, in plain English: The airbag system — the part that is supposed to protect you in a crash. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
What could happen: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
The fix: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 SILVERADO 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 24V756000 (manufacturer code N242474500).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR
Summary: General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2018 Chevrolet Silverado 3500 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (7), Fuel system (5), Electrical system (4), Diesel (3), Unknown Or Other (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/24/2026 · Fuel system
The high pressure fuel pump failed and sent metal particles throught the fuel system. All fuel components except for the injectors are available. The engine stalled while driving at speed forcing me to stop and call a tow truck on the side of the road. Mileage at failure was 81340. Preston hood Chevrolet diagnosed the HP4 failure and replaced the entire fue…
04/20/2026 · Electrical system
Recall N192265660 repair failed. Dealer stated that GM refused to participate in the repair. Smoke and smell of burning electrical followed by the rear window exploding. Dealer quoted over $1900 to repair and suggested we go aftermarket and have the repair done elsewhere. Vehicle has approximately 62k miles since last attempt to repair the recall.
01/15/2026 · Steering
I’ve heard all the horror stories about faulty electrical issues. I’m chasing an issue now on my 2018 with ONLY 87,000 miles after spending a bunch of money on batteries hub assemblies random control modules to try to fix an issue of stabilitrak, traction control, abs, trailer brakes, power steering etc all going off every 3 seconds. Grounds have all been r…
01/28/2025 · Fuel system
The contact owned a 2018 Chevrolet Silverado 3500 Commercial Vehicle. The contact received notifications of NHTSA Campaign Numbers: 21V496000 (Equipment) and 23V047000(Fuel System, Diesel) and would like to be removed from the recall distribution list because the vehicle was totaled. The manufacturer was contacted.
10/24/2024 · Engine
The contact owns 2018 Chevrolet Silverado 3500. The contact stated while driving 70 MPH, the engine started misfiring and made an abnormal knocking sound. Additionally, the vehicle was shuddering. The check engine warning light was illuminated, and the message "Engine Power Reduced" was displayed. The contact was able to pull over to the side of the road, w…
08/24/2023 · Unknown Or Other
46000 miles and the oil pan rotting from the salt on the roads i have an extended warranty no one wants to cover the warranty it has 100000 power train warranty and no one wants to be responsible for it
06/05/2023 · Fuel system
The contact owns a 2018 Chevrolet Silverado 3500. The contact stated that the fuel tank had collapsed. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that the fuel pump and rear fuel tank needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted…
02/15/2022 · Steering
stabilitrak system truck speeds up when braking,and pulls left or right transmission shift hard when warning lights come on intermittently