1994 Chevrolet Tahoe recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
What could happen: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
The fix: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-878…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 TAHOE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 03V159000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes: GM RECALL NO. 03023. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
What could happen: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 TAHOE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 98V150001.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes: OWNER NOTIFICATION BEGAN DECEMBER 15, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (10), Hydraulic (10), Engine (3), Visibility (wipers / glass) (3), Electrical system (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/05/2008 · Brakes
TL*THE CONTACT OWNS A 1994 CHEVROLET TAHOE S10. WHILE DRIVING OVER A BUMP AT ANY SPEED, THE CONTACT DEPRESSED THE BRAKE PEDAL. THE ABS ENGAGED AND THE VEHICLE LOST BRAKING ABILITY. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THERE WERE NO CURRENT RECALLS THAT APPLIED TO HIS VIN. THE CURRENT AND FAILURE MILEA…
12/15/2003 · Visibility (wipers / glass)
WINDSHIELD WIPER MOTOR WAS DEFECTIVE. WINDSHIELD WIPERS WORKED INTERMITTENTLY IN INCLEMENT WEATHER. A RECALL WAS ISSUED ON THIS MAKE/MODEL AND YEAR; HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
09/07/2003 · Electrical system
MY S10 TAHOE BEGAN SPUTTERING AND STALLING COMPLETELY WITHOUT WARNING LAST WEEKEND. I JUST PICKED IT UP FROM THE SHOP AFTER HAVING THE EGR VALVE CLEANED (AMONG SEVERAL OTHER THINGS), ONLY TO HAVE IT LAST FOR THE 20 MINUTE DRIVE HOME BEFORE IT STARTED ACTING UP AGAIN. I WAS TOLD THAT IT MAY STILL BE THE EGR VALVE BEING CLOGGED AGAIN - AND TO EXPECT THAT TO…
10/28/2002 · Engine
A INTERNAL FUEL LINE INSIDE OF VORTEC MOTOR RUPTURE AND FUEL SPILL ALL OVER HIS ENGINE. THE DEALERSHIP IS AWARE OF THE PROBLEM. TS
05/23/2002 · Visibility (wipers / glass)
THE WINDSHIELD WIPER FAILED. THE CONSUMER STATES THERE WAS A RECALL FOR THOSE PARTS BUT THE RECALL DOES NOT INCLUDE THE VEHICLE BECAUSE OF THE VIN. *YH
03/25/2002 · Seats
WHILE DRIVING 5 MPH DRIVER SEATBACK BROKE, NO INJURIES. *AK
02/07/2002 · Brakes
IN DECEMBER 2001 THE BRAKE SYSTEM TOTALLY FAILED FOR AN INSTANT IN HEAVY TRAFFIC VERY NEARLY CAUSING A REAR END COLLISION. AGAIN ON FEB 6, 2002 THE SAME THING OCCURRED, AGAIN IN HEAVY TRAFFIC. I WILL PRESENT THE VEHICLE TO A CHEVROLET DEALER IN HOPES OF HAVING IT FIXED. *AK
07/13/2001 · Visibility (wipers / glass)
RECALL 98 V 150 000/WINDSHIELD WIPER WIRING: WINDSHIELD WIPERS WORK INTERMITTENTLY, RESULTING IN INOPERATIVE WIPERS, REDUCING DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH; DEALER WAS NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER RECALL DUE TO VIN. AK *SLC