1991 Ford Club Wagon recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (3), Fuel system (2), Gasoline (2), Wheels / tires (2), Electrical system (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
12/06/2002 · Fuel system
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP. DT
09/18/2001 · Electrical system
CONSUMER IS HAVING PROBLEMS WITH A DEFECTIVE IGNITION SWITCH THAT IS POSSIBLY CAUSING VEHICLE TO STALL. *TT
06/27/2001 · Wheels / tires · crash
CONSUMER WAS TRAVELING ABOUT 70MPH ON HIGHWAY AND HEARD A NOISE. VEHICLE WAS STRADLING FROM LANE TO LANE, AND THEN ROLLED OVER. TWO CHILDREN WERE EJECTED FROM VEHICLE. REAR DRIVER'S SIDE TIRE BLEWOUT, AND THE TREAD CAME COMPLETLY OFF. TIRE WAS GOODYEAR. *AK
08/10/2000 · Wheels / tires
TREAD DETACHED FROM TIRE AT 70 MPH. CASING RETAINED PRESSURE, SO WAS ABLE TO COME TO SAFE STOP AND THEN DRIVE SLOWLY ON SHOULDER TO FREEWAY EXIT. *AK( DOT NUMBER: TIRE SIZE: P235/75R15 )
07/25/2000 · Fuel system
ESCORT FUEL PUMP ASSEMBLY RESULTED IN HIGH PRESSURE MASSIVE GASOLINE LEAKS, FUEL PUMPS ARE UNDER THE BACK SEATS. WHEN THE FUEL PUMP LEAK THE PRESSURE IS LIKE A GARDEN HOSE SPEWING GASOLINE
06/27/2000 · Engine
THE HEAD GASKET FAILED IN THE ENGINE. THE REPAIR BILL WAS $627.69. I TALKED TO FORD MOTOR COMPANY'S CUSTOMER SERVICE DEPT. THEY DECLINED TO PAY FOR REPAIR EVEN THOUGH THE FAILURE IS A KNOWN DESIGN DEFECT. *AK
10/05/1999 · Transmission / drivetrain
TRANSMISSION MAKING GRINDING NOISES. NOT SHIFTING INTO GEAR. WAS REPLACED TWICE. AFTER EACH REPLACEMENT, NOISE WOULD REAPPEAR. BEEN TO TRANSMISSION SHOP, BUT NOT DEALER. *AK
10/20/1997 · Trailer Hitches
TRAILER HITCH FAILED CAUSING LOAD TO SEPARATE FROM VEHICLE. (OHIO STATE POLICE REPORT)