1982 Ford Econoline recalls & complaints

1. Fuel system

What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

What could happen: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

The fix: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1982 ECONOLINE.
2. Book a repair at any authorized Ford dealer. Quote NHTSA campaign 07E064000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

2. Transmission / drivetrain

What's wrong, in plain English: The parts that send engine power to the wheels. Failure can mean a sudden loss of power or the car rolling away. ON SOME OF THE INVOLVED VEHICLES, THE SHIFT ROD IN THE TRANSMISSION MAY NOT BE PROPERLY SEATED IN THE RETENTION GROMMET OF THE STEERING COLUMN SHIFT LEVER ASSEMBLY. IF THE SHIFT ROD WERE TO DISENGAGE, THE DRIVER COULD NOT SELECT THE PROPER TRANSMISSION FUNCTION WHICH WOULD CREATE THE POTENTIAL FOR UNEXPECTED MOVEMENT OF THE VEHICLE.

What could happen:

The fix: DEALER WILL INSPECT THE SHIFT ROD ATTACHMENT AND MAKE SURE IT IS PROPERLY SEATED AT NO COST TO OWNER.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1982 ECONOLINE.
2. Book a repair at any authorized Ford dealer. Quote NHTSA campaign 82V004000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

3. Fuel system

What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. THE INVOLVED VEHICLES MAY NOT MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN A MOVING BARRIER IMPACT TEST FROM THE REAR AT 30 MPH, THE FASTENER ATTACHING THE FUEL SENDER GROUND WIRE TO THE FRAME CROSSMEMBER, AFT OF THE FUEL TANK, PIERCED THE FUEL TANK.

What could happen:

The fix: THE FUEL SENDER GROUND WIRE ATTACHMENT ON ALL AFFECTED VEHICLES WILL BE RELOCATED TO ELIMINATE THE DANGER, WITHOUT CHARGE TO OWNER.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1982 ECONOLINE.
2. Book a repair at any authorized Ford dealer. Quote NHTSA campaign 81V105000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

Owner complaints filed with NHTSA

Most complained-about parts: Seat belts (1).

Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.