2019 Ford F-250 Supercab recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
What could happen: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
The fix: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2019 F-250 SUPERCAB.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 18V894000 (manufacturer code 18S45).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-436-7332.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE
Summary: Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Seats
What's wrong, in plain English: Seat frames, adjusters or child-seat anchors. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207,…
What could happen: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
The fix: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2019 F-250 SUPERCAB.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 19V633000 (manufacturer code 19C07).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-436-7332.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEATS:FRONT ASSEMBLY:RECLINER
Summary: Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Transmission / drivetrain
What's wrong, in plain English: The parts that send engine power to the wheels. Failure can mean a sudden loss of power or the car rolling away. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.
What could happen: An improperly welded axle may affect vehicle control, increasing the risk of a crash.
The fix: Ford will notify owners and dealers will inspect the front axle wheel yoke weld location. If the weld is found to be inaccurately located, the axle assembly will be replaced free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2019 F-250 SUPERCAB.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 20V576000 (manufacturer code 20S56).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-436-7332.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: POWER TRAIN:AXLE ASSEMBLY
Summary: Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.
Consequence: An improperly welded axle may affect vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners and dealers will inspect the front axle wheel yoke weld location. If the weld is found to be inaccurately located, the axle assembly will be replaced free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S56.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Transmission / drivetrain
What's wrong, in plain English: The parts that send engine power to the wheels. Failure can mean a sudden loss of power or the car rolling away. The passenger side rear axle shaft may fail prematurely due to a material issue.
What could happen: A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will inspect the passenger side rear axle shaft, replacing it as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S31.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2019 F-250 SUPERCAB.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 19V688000 (manufacturer code 19S31).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-436-7332.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Summary: Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.
Consequence: A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the passenger side rear axle shaft, replacing it as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S31.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2019 Ford F-250 Supercab owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Steering (769), Suspension (674), Unknown Or Other (110), Wheels / tires (91), Fuel system (47).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/05/2026 · Steering
Experienced the oft reported death wobble while driving home from TN and had to limp my vehicle home while experiencing the constant, extreme and dangerous wobbling.
06/29/2026 · Visibility (wipers / glass)
The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 65 MPH on a cross-country move, the rear windshield was loose and was shaking inside the frame. The contact stated the rear glass remained attached and hanging within the frame. The vehicle was taken to a dealer to be diagnosed. The dealer replaced the rear window frame…
06/20/2026 · Transmission / drivetrain
At around 139,000 miles i started to noticed some intermittent noise coming from the drivetrain. I took it to two different repair shops and was told it was tire noise. over time the grinding noise increased to the point of shuddering and jerking while shifting with no warning lamps showing. At 144,500 miles I contacted my aftermarket warranty and they said…
05/24/2026 · Transmission / drivetrain
My truck transmission changes gears randomly while in motion. It is terrifying when it happens in traffic and the truck stalls and looses power then kicks back in with a loud noise. I stopped driving it since March of 2026.
05/12/2026 · Fuel system
Original Fuel pump stated intermittent long cracks about 35,000 miles. And continues to do so. It seems like FORD uses the all time favorite “ we cannot recreate the issue” in order to send the customer on their way and not take ANY responsibility whatsoever ,WOW! Its rediculous that they don’t want to acknowledge the issue after thousands of customers com…
04/04/2026 · Suspension
While driving at highway speeds, I drove over an expansion joint on a bridge and experienced violent shaking of the vehicle. This included violent shaking of the steering wheel and interior of the truck. I also slowed down to under 30 mph on the highway to stop the shaking. This occurred several other times and, upon researching, found it to be called a…
03/31/2026 · Fuel system
My husband was driving our 2019 F250 on the highway at over 75 mph and the truck totally shut down/stalled without warning, could have killed him or another person, lucky he was able to coast to the shoulder and stop, we took to the Ford dealership and was caused by the faulty CP4 fuel pump the truck was made with that has had class action lawsuits and reca…
03/25/2026 · Wheels / tires
The contact owns a 2019 Ford F-250 equipped with Cooper Tires, Tire Line: Discoverer AT3, Tire Size: 295/60/R20, DOT Number: (N/A). The contact stated that while driving 60 MPH and hauling a trailer, the vehicle jolted into oncoming traffic and started wobbling. The contact regained control of the vehicle and eventually steered to the side of the road and p…