2005 Ford Five Hundred recalls & complaints

Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Notes: THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Summary: ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 05S37. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 06S45. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

08/19/2025 · Transmission / drivetrain
The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 M…

03/09/2024 · Electrical system
I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 miles and drive up to sixty mile…

08/22/2023 · Suspension · crash
I have 2 very serious and dangerous issues. The 1st issue, the car will shut off while driving and without warning. I'll be cruzing down the highway and out of no where it shuts off. I then do not have breaks or power stearing. This last Winter my daughter was driving it and it shut off while she was on black ice. The car flew into the ditch and the snow wa…

07/08/2023 · Electrical system
The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically an shifts an downshifts hard.

07/08/2023 · Steering
While driving the front end suspension slips, bounces up and down very harshly, tires slip, squeak, and slide in an hard to control way, sometimes into oncoming traffic when in slightly damp conditions an on roads with any amount of bumps, to the point that I need to drive extremely slow to avoid danger which in turn puts my and my passengers and my kids in…

07/12/2022 · Transmission / drivetrain
While waiting at the light in traffic, my car all of a sudden Accelerated, and decelerates, I have to push hard on the breaks in order for it to not slam into the cars infront of me.. this is really dangerous, from what I have been reading this is a wide spread issue that ford has ignored for years..

06/20/2022 · Vehicle Speed Control
while we are in idel for a period of time the car wants to surge forward without pushing on the gas. it wants to rev withough the has pedal being pushed. It does it at red lights, stop signs, and if Im in a drive through.

08/20/2021 · Engine
The contact owns a 2005 Ford Five Hundred. The contact stated that while starting the vehicle, the "fail safe engine mode" and check engine warning lights were illuminated. The vehicle stalled with the RPM revved up. The vehicle jerked while driving at an undisclosed speed. The dealer nor the independent mechanic was not made aware of the failure. The vehic…