1996 Ford Probe recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. CERTAIN SPX FILTRAN FUEL FILTERS…
What could happen: IN THE PRESENCE OF AN IGNITION SOURCE, A VEHICLE FIRE CAN OCCUR.
The fix: SPX WILL NOTIFY ITS CUSTOMERS AND PROVIDE A FULL REFUND. THE RECALL BEGAN SEPTEMBER 27, 2005. OWNERS MAY CONTACT MR. CHRIS GREESON AT 704-869-3733 OR CONTACT THE WIX INFORMATION HOTLINE AT 800-949-6698.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 PROBE.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 05E065000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS.
CERTAIN SPX FILTRAN FUEL FILTERS WITH A 90-DEGREE ANGLE INLET TUBE, MODEL 800F300-S2, SOLD AS REPLACEMENT FILTERS FOR 19983-1994 SUBARU VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS.
FUEL MAY LEAK FROM THE FILTER DUE TO NON-CONFORMING BRAZING WELDS WHERE THE INLET TUBE IS CONNECTED TO THE FILTER CAN.
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A VEHICLE FIRE CAN OCCUR.
Remedy: SPX WILL NOTIFY ITS CUSTOMERS AND PROVIDE A FULL REFUND. THE RECALL BEGAN SEPTEMBER 27, 2005. OWNERS MAY CONTACT MR. CHRIS GREESON AT 704-869-3733 OR CONTACT THE WIX INFORMATION HOTLINE AT 800-949-6698.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY:1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
What could happen: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 PROBE.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 06E026000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
What could happen: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
The fix: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 PROBE.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 06E065000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes: THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
4. Airbags
What's wrong, in plain English: The airbag system — the part that is supposed to protect you in a crash. THE SUPPLEMENTARY AIR BAG INFLATABLE RESTRAINT CAUTION LABEL LOCATED ON THE DRIVER SIDE SUN VISOR DOES NOT CONTAIN THE STATEMENT, "DO NOT INSTALL REARWARD FACING CHILD SEATS IN ANY FRONT PASSENGER SEAT POSITION." THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
What could happen: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
The fix: A NEW CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS CAN INSTALL THE LABEL OR, IF THEY WISH, CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 PROBE.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 96V090000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: AIR BAGS
Summary: THE SUPPLEMENTARY AIR BAG INFLATABLE RESTRAINT CAUTION LABEL LOCATED ON THE DRIVER SIDE SUN VISOR DOES NOT CONTAIN THE STATEMENT, "DO NOT INSTALL REARWARD FACING CHILD SEATS IN ANY FRONT PASSENGER SEAT POSITION." THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
Remedy: A NEW CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS CAN INSTALL THE LABEL OR, IF THEY WISH, CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Notes: SYSTEM: INTERIOR; PASSIVE RESTRAINT; AIR BAG; FMVSS NO. 208. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE JULY 17, 1996. NOTE: OWNERS WHO DO NOT RECEIVE THE NEW CAUTION LABEL WITHIN A REASONABLE TIME WITHOUT CHARGE CAN CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1996 Ford Probe owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (19), Transmission / drivetrain (18), Steering (10), Electrical system (7), Suspension (5).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
05/19/2011 · Suspension
REPLACED RIGHT LOWER CONTROL ARM ASSEMBLY WITH A NEW PART FROM O'REILLY AUTOPARTS STORE ON 8/31/10 AND ON 11/05/10 THE BALL JOINT CAME COMPLETELY OUT OF THE NEW CONTROL ARM MAKING AN EXTREMELY UNSAFE DRIVING CONDITION. DEFECTIVE NEW PART, REPLACED IT AGAIN ON 11/09/10 WITH ANOTHER NEW REPLACEMENT PART FROM O'REILLY AUTOPARTS STORE. *TR
10/10/2008 · Engine
FIRST MY ENGINE SEEMED TO OVERHEAT A BIT THEN EVERY ONCE IN A WHILE IT WOULD SOUND LIKE THE ENGINE WAS GRINDING ON SOMETHING AND WOULDN'T STOP.. SOUNDED LIKE A BUNCH OF CHAINS IN MY HOOD. BUT THEN ON OCCASIONS THE STUPID THING WOULDN'T SHUT OFF WHEN IT WAS MAKING THE CHAIN SOUND, EVEN WITH MY KEY OUT. IT JUST HAPPENED AGAIN AND NOW THE THING SMELLS LIKE SOM…
07/16/2008 · Suspension
LT FRONT SPRING BROKE & PUNCTURED THE INSIDE SIDEWALL OF THE TIRE MAKING IT GO FLAT. *TR
06/24/2008 · Transmission / drivetrain
AUTOMATIC TRANSMISSION FAILURE. SECOND TIME. THIS NEEDS TO BE ADDRESSED VERY EXPENSIVE TO REPAIR. *TR
01/18/2008 · Airbags
1996 FORD EXPLORER, 4X4. DRIVING IN DESERT WENT OVER A BUMP A LITTLE FAST, WHICH SET OFF MY AIRBAGS. MY RIDER IS IN THE HOSPITAL FOR BROKEN NOSE, CHEEK AND SOME KIND OF SMOKE INHALATION. MY WINDSHIELD IS BROKEN BECAUSE THE BAG HIT THE MIRROR WHICH THEN HIT THE WINDSHIELD. MY STEERING WHEEL IS DESTROYED, CRUISE CONTROL AND HORNS ARE OUT OF SERVICE. BEFOR…
12/07/2007 · Fuel system
MY 1996 MERCURY VILLAGER DEVELOPED A FAILURE IN THE AIR FLOW SENSOR (PART $330) THAT RESULTED IN VEHICLE STALLS, INCLUDING STOPS ON THE HIGHWAY, THAT NEARLY RESULTED IN CRASHES. THE REQUIRED REPAIRS EXCEEDED $500. I KNOW FORD HAS A SIMILAR RECALL OUT NOW FOR THE 1997-2003 (/) MODELS). *TR
07/03/2007 · Wheels / tires · crash
TIRE ON 2 CASES BLEW THE TREAD AND BELT, THE LATER OF THE TWO INCIDENCES WHICH RESULTED IN A CRASH THAT TOTALED THE VEHICLE, AND RESULTED IN TWO INJURIES TO BOTH THE DRIVER AND THE PASSENGER. BOTH NEEDED TO BE HOSPITALIZED.*AK
11/18/2006 · Transmission / drivetrain
1996 FORD PROBE SE AUTO TRANSMISSION FAILURE,SAME AS MAZDA 626 ALL OF THESE CARS HAVE THE SAME PROBLEM THAT COST THOUSANDS TO FIX,CHECK THE INTERNET,WHY HASN'T THERE BEEN A RECALL?