1996 Ford Thunderbird recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
What could happen: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 09E012000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-909-598-7589.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
What could happen: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
The fix: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 06E065000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes: THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
What could happen: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
The fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 96V070000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Notes: VEHICLE DESCRIPTION: PASSENGER, MULTI-PURPOSE VEHICLES AND MINI-VANS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
What could happen: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 96V007000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Summary: UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
Notes: SYSTEM: AIR CONDITIONER; ELECTRONIC CLIMATE CONTROL MODULE. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH OPTIONAL SEMI-AUTOMATIC TEMPERATURE CONTROL SYSTEM. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1996 Ford Thunderbird owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (70), Brakes (52), Hydraulic (52), Transmission / drivetrain (23), Visibility (wipers / glass) (21).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/22/2019 · Airbags
AIR BAG FLASHING CODE
01/19/2016 · Airbags
WHEN DRIVING THE AIR BAG LIGHT BEGAN BLINKING THE HORN AND CRUISE CONTROL SWITCHESYSTEM STOPPED WORKING IN MOTION FAILURE OF THE CLOCK SPRING
07/12/2011 · Engine
TL* THE CONTACT OWNS A 1996 FORD THUNDERBIRD. THE CONTACT WAS DRIVING 30 MPH WHEN HE NOTICED AN ABNORMALLY STRONG COOLANT ODOR. THE CONTACT THEN INSPECTED THE VEHICLE AND FOUND THAT THE ANTIFREEZE INTAKE MANIFOLD HAD FAILED. THE INTACT MANIFOLD WAS CRACKED AND CAUSING ANTIFREEZE TO SPILL. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED.…
05/10/2011 · Equipment
TL*THE CONTACT OWNS A 1996 FORD THUNDERBIRD. WHILE DRIVING APPROXIMATELY 25 MPH WITH THE AIR CONDITIONER ACTIVATED THE FAN BLOWER STOPPED FUNCTIONING. THE CONTACT STATED THE FAILURE ALSO OCCURRED WHEN THE HEAT OR DEFROSTER WAS ACTIVATED. THE FUNCTIONS WOULD ALSO OPERATE ERRATICALLY CAUSING THE FAN BLOWER TO GO FROM HIGH TO LOW ON ITS OWN. THE VEHICLE WAS NO…
10/10/2008 · Engine
FIRST MY ENGINE SEEMED TO OVERHEAT A BIT THEN EVERY ONCE IN A WHILE IT WOULD SOUND LIKE THE ENGINE WAS GRINDING ON SOMETHING AND WOULDN'T STOP.. SOUNDED LIKE A BUNCH OF CHAINS IN MY HOOD. BUT THEN ON OCCASIONS THE STUPID THING WOULDN'T SHUT OFF WHEN IT WAS MAKING THE CHAIN SOUND, EVEN WITH MY KEY OUT. IT JUST HAPPENED AGAIN AND NOW THE THING SMELLS LIKE SOM…
03/17/2008 · Body / structure
OPENING DOORS FROM THE INSIDE, LITTLE BY LITTLE, BOTH DOORS FAILED TO OPEN FROM THE INSIDE, HAD TO LEAVE WINDOW OR WINDOWS OPEN TO STICK HAND OUT TO OPEN DOOR FROM THE OUTSIDE. FAILURE OF THESE DOORS TO FUNCTION PROPERLY AT SOME POINT IF BATTERY WOULD GIVE OUT WOULD LEAVE US LOCKED IN, BUT FORTUNATELY THAT DID NOT HAPPEN DUE TO US REMEMBERING TO LEAVE AT LE…
01/18/2008 · Airbags
1996 FORD EXPLORER, 4X4. DRIVING IN DESERT WENT OVER A BUMP A LITTLE FAST, WHICH SET OFF MY AIRBAGS. MY RIDER IS IN THE HOSPITAL FOR BROKEN NOSE, CHEEK AND SOME KIND OF SMOKE INHALATION. MY WINDSHIELD IS BROKEN BECAUSE THE BAG HIT THE MIRROR WHICH THEN HIT THE WINDSHIELD. MY STEERING WHEEL IS DESTROYED, CRUISE CONTROL AND HORNS ARE OUT OF SERVICE. BEFOR…
12/07/2007 · Fuel system
MY 1996 MERCURY VILLAGER DEVELOPED A FAILURE IN THE AIR FLOW SENSOR (PART $330) THAT RESULTED IN VEHICLE STALLS, INCLUDING STOPS ON THE HIGHWAY, THAT NEARLY RESULTED IN CRASHES. THE REQUIRED REPAIRS EXCEEDED $500. I KNOW FORD HAS A SIMILAR RECALL OUT NOW FOR THE 1997-2003 (/) MODELS). *TR