2002 Ford Thunderbird recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
What could happen: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The fix: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 06E056000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Notes: THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST.
What could happen: THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH.
The fix: DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 02V169000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-436-7332.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:WEBBING
Summary: ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST.
Consequence: THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH.
Remedy: DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2002 Ford Thunderbird owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (36), Electrical system (21), Airbags (13), Vehicle Speed Control (11), Steering (4).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/05/2023 · Steering
The contact owns a 2002 Ford Thunderbird. The contact stated while driving 5 MPH and attempting to make a turn, the steering wheel seized. There was no warning light illuminated. The contact was able to turn the steering wheel while using excessive force and veered to the side of the roadway. The contact stated that he restarted the vehicle; however, the ve…
09/05/2023 · Steering
The contact owns a 2002 Ford Thunderbird. The contact stated that while driving approximately 15 MPH and making a left turn, the power steering suddenly failed and the steering wheel would not turn in either direction, before the vehicle suddenly stalled. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The loca…
08/19/2019 · Electrical system
THE CLUSTER LIGHTS HAVE GONE OUT ON MY 2002 FORD THUNDERBIRD. WHEN THIS ACTUALLY HAPPENED I REALLY DON'T KNOW SINCE THE CAR IS MAINLY A SHOW CAR AND WHILE DRIVING THE CAR AT DUSK COMING BACK FROM A CAR SHOW THE CLUSTER LIGHTS DID NOT COME ON. WE PARKED THE CAR AND ONLY DROVE IT DURING DAYLIGHT HOURS. THEN THE FUEL SYSTEM QUIT WORKING SO WE HAD TO HAVE THE C…
03/14/2019 · Wheels / tires
TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD EQUIPPED WITH A FIRESTONE TEMPA SPARE TIRE, SIZE: T185-60-R17 (NA). WHILE CLEANING THE VEHICLE, THE CONTACT FOUND THAT THE SPARE TIRE THAT WAS STORED IN THE TRUNK WAS BLOWN OUT AND THE TIRE WIRES, RUBBER, AND CORDS WERE EXPOSED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO VISIT FIRESTONE TO HAVE THE…
02/25/2019 · Airbags · crash
MY DAUGHTER WAS IN A ROLLOVER ACCIDENT ON 09 -06 -2016 IN A 2002 FORD THUNDERBIRD CONVERTIBLE. THE AIR BAG DID NOT SUFFICIENTLY DEPLOY & SHE WAS SEVERELY INJURED AS A RESULT. SHE WAS ON INTERSTATE 95N NEAR MANNING, SC WHEN A SEMI TRUCK DID NOT SEE HER & CAME INTO HER LANE GRAZING THE CAR. SHE HAD TO GO OFF THE ROAD OR THE TRUCK WOULD HAVE CRUSHED HER. THE…
11/01/2018 · Airbags
MY AIRBAG LIGHT IS ON AND I WANT TO KNOW IF I HAVE A TAKATA AIRBAG. IF SO HOW TO I GET IT FIXED?
05/21/2018 · Airbags
AIR BAG NEEDS TO BE REPLACED AND FORD HAS NO REPAIR PARTS AVAILABLE TO PROVIDE OCCUPANT PROTECTION IN THE EVENT OF A CRASH. *JS
04/23/2018 · Airbags
AIR BAG WARNING LIGHT APPEARED ON INSTRUMENT PANEL AND OWNER'S MANUAL INSTRUCTED TO RETURN TO DEALER. DEALER DIAGNOSED THE PROBLEM AS A FAULTY AIR BAG THAT SHOULD BE REPLACED. FORD MOTOR CO. SAID SERVICE PARTS ARE NOT AVAILABLE AND DEALER DID NOT REPAIR THE AIR BAG. I WAS ALLOWED TO LEAVE THE SERVICE DEPARTMENT WITH NO IDEA IF THE AIR BAG WOULD FUNCTION I…