2008 Harley-Davidson Fxd recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. ON CERTAIN MOTORCYCLES BUILT AND SHIPPED TO CALIFORNIA, THE CATALYTIC MUFFLER PROTECTIVE HEAT SHIELD WAS NOT INSTALLED. THIS CONDITION COULD ALLOW DIRECT CONTACT WITH THIS MUFFLER AND CAUSE INJURY.
What could happen: IF CONTACT OCCURS WHILE RIDING, IT COULD CAUSE LOSS OF CONTROL OF THE MOTORCYCLE, LEADING TO INJURY OR DEATH.
The fix: DEALERS WILL INSTALL THE HEAT SHIELDS TO THE MUFFLERS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 26, 2007. OWNERS MAY CONTACT HARLEY DAVIDSON AT 1-414-343-4056.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2008 FXD.
- Book a repair at any authorized Harley-Davidson dealer. Quote NHTSA campaign 07V535000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-414-343-4056.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Summary: ON CERTAIN MOTORCYCLES BUILT AND SHIPPED TO CALIFORNIA, THE CATALYTIC MUFFLER PROTECTIVE HEAT SHIELD WAS NOT INSTALLED. THIS CONDITION COULD ALLOW DIRECT CONTACT WITH THIS MUFFLER AND CAUSE INJURY.
Consequence: IF CONTACT OCCURS WHILE RIDING, IT COULD CAUSE LOSS OF CONTROL OF THE MOTORCYCLE, LEADING TO INJURY OR DEATH.
Remedy: DEALERS WILL INSTALL THE HEAT SHIELDS TO THE MUFFLERS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 26, 2007. OWNERS MAY CONTACT HARLEY DAVIDSON AT 1-414-343-4056.
Notes: HARLEY-DAVIDSON RECALL NO. 0133. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2008 Harley-Davidson Fxd owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (5), Gasoline (3), Other (2), Suspension (1), Brakes (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (7)
05/10/2011 · Suspension
2008 HARLEY DAVIDSON FXD DYNA SUPER GLYDE. CONSUMER WRITES IN REGARDS TO WHEEL BEARING PROBLEMS *TGW THE CONSUMER STATED AT 8368 MILES, THE REAR WHEEL BEARING FAILED. THE MECHANIC INFORMED THE CONSUMER IT WAS A COMMON PROBLEM WITH ALL THE 2008 AND NEWER MODELS. THE CONSUMER STATED THE MANUFACTURER CHANGED THE BEARING FROM 1 INCH TO 25MM. *JB
10/06/2010 · Fuel system
TL*THE CONTACT OWNS A 2008 HARLEY DAVIDSON NIGHT RIDER SPECIAL MOTORCYCLE (NA). WHILE DRIVING 45 MPH, THE VEHICLE SUDDENLY RAN OUT OF FUEL. THE CONTACT STATED THAT THE FUEL GAUGE INDICATED THAT THE TANK WAS FULL. THE FAILURE HAD OCCURRED SINCE APRIL 2008. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FUEL SENDING UNIT WAS REPLACED. THE FAILURE OCC…
07/22/2010 · Fuel system
MY BRAND NEW 2008 HARLEY DAVIDSON NIGHT ROD (VRSCD) CAME WITH A FAULTY FUEL GAUGE (SENDER). TOOK IT INTO THE DEALERSHIP FOR A WARRANTY REPLACEMENT. THE GAUGE (SENDER) WAS REPLACED, BUT THE PROBLEM CONTINUED. THE GAUGE DISPLAYS INCORRECTLY ALL THE TIME. I'M RESORTING TO RESETTING THE TRIP ODOMETER AT EVERY FILL-UP TO ENDURE THAT I DON'T RUN OUT OF FUEL.…
07/01/2008 · Fuel system · fire
FUEL PUMP ON 2008 HARLEY ULTRA CLASSIC CAUSED PIPES TO GET SO HOT ( GLOWING RED )WHEN I CHECKED OIL LEVEL THE RAG I WAS USING CAUGHT ON FIRE. ALSO THE PIPES ARE NOW REALLY DISCOLORED AND HARLEY WON'T REPLACE THEM BACK TO ORIGINAL CONDITION. THEY WON'T EVEN CHANGE THE OIL THAT I'M SURE WAS BROKEN DOWN BY THE HEAT. *TR
06/24/2008 · Brakes
REAR BRAKES SQUEAL ON BRAND NEW 2008 HARLEY DAVIDSON FLHTC: VEHICLE CHOICES WERE NOT SUFFICIENT TO LIST THIS MODEL. *TR
06/20/2008 · Fuel system
THE "TOP PLATE ASSEMBLY" PART # 75076-08 ON MY 2008 HARLEY DAVIDSON ROAD KING CLASSIC FAILED. THE FUEL FILTER HOUSING IN THIS ASSEMBLY CRACKED AND THE MOTORCYCLE SUDDENLY AND ABRUPTLY LOST POWER IN TRAFFIC. THIS VEHICLE HAS APPROXIMATELY 2,100 MILES AND 9 MONTHS OF USE SINCE NEW. THERE HAVE BEEN MANY INSTANCES OF THIS DOCUMENTED ON THE "HD FORUMS" WEBSIT…
05/30/2008 · Fuel system
UNCONTROLLABLE IDLE, HARLEY DAVIDSON FLY BY WIRE THROTTLE. IDLE INTERMITTENTLY WILL GO ABOVE 1800 RPM. A FACTORY KNOWN ISSUE WITH NO PERMANENT REPAIR OR REPLACEMENT. I HAVE HAD THIS BIKE 2 MONTHS NOW IT IT HAS HAPPENED AT LEAST 8 TIMES. DEALERSHIP SAID IT WAS HOW I TURNED MY BIKE OFF. THEY SAID TO TURN THE IGNITION ON AND OFF 2-3 TIMES TO RESET THE THROT…