2003 Honda Vfr800 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
What could happen: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
The fix: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 VFR800.
- Book a repair at any authorized Honda dealer. Quote NHTSA campaign 07V359000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-784-1870.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:WIRING
Summary: ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
Consequence: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY CONTACT HONDA AT 1-866-784-1870.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
What could happen: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
The fix: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 VFR800.
- Book a repair at any authorized Honda dealer. Quote NHTSA campaign 05V010000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC
Summary: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Consequence: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
Notes: HONDA RECALL NO. P65. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Portable jump starter
- 2003 Honda Vfr800 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (8), Lights (1), Fuel system (1), Gasoline (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/23/2013 · Electrical system
MY ISSUE WAS FIRST DISCOVERED IN 2012 WHEN I COULD NOT START MY MOTORCYCLE; MY FIRST THOUGHT WAS AN OLD BATTERY. UPON RESEARCHING ON VFRDISCUSSION.COM I WAS EXPOSED TO NUMEROUS VFR OWNERS WITH STARTING ISSUES THAT WAS RELATED TO THE ELECTRICAL AND CHARGING ISSUES, A KNOWN ISSUE WITH MY 2003 MODEL YEAR. FROM THE INFORMATION GATHERED I STARTED TO INVESTIGATE…
09/05/2007 · Electrical system
TL*THE CONTACT OWNS A 2003 HONDA VFR800. WHILE RIDING 70 MPH, THE HEADLIGHT SHUT OFF WITHOUT WARNING. THE CONTACT BELIEVED THAT THE FRONT FAIRING SUB-HARNESS TRANSFERRED THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHT TO OTHER COMPONENTS AND CAUSED THE FAILURE. NHTSA CAMPAIGN ID NUMBER 07V359000 (ELECTRICAL SYSTEM:WIRING) WAS REFERENCED. THE DEALER HAS N…
07/10/2007 · Electrical system
2003 HONDA VFR MOTORCYCLE SHUT OFF WHILE OPERATING AT APPROX. 30 MPH / 3500 RPM. SAFELY PULLED OFF ROAD AND PARKED. HEADLIGHTS & DASHBOARD LIGHTS DIM, BUZZING SOUND FROM DASHBOARD. BIKE RESTARTED ONLY WHEN HEADLIGHT FUSE WAS REMOVED. BIKE CURRENTLY AT HONDA DEALER FOR REPAIRS. EXTENSIVE DISCUSSION OF THIS PROBLEM, SOLUTION, AND ELECTRICAL SYSTEM DESIGN…
01/07/2006 · Electrical system
REGARDING INVESTIGATION PE05047 THIS INVESTIGATION WAS CLOSED 12/20/05, BUT I HAVE READ MANY COMPLAINTS FROM OWNERS OF THIS MODEL THAT ARE HAVING THE SAME PROBLEM. MY HONDA VFR800 SHOWS SIGNS OF FAILURE DURING NORMAL USE AND THERE ARE NO "MODIFICATIONS TO THE WIRING HARNESS" AS SUGGESTED BY YOUR INVESTIGATION. THE ONLY AUXILIARY LOADS I HAVE ON MY BIKE…
11/14/2005 · Electrical system
DT: THE CONTACT STATED THE ELECTRICAL SYSTEM BURNED. THIS CAUSED THE HEADLIGHTS NOT TO WORK. THE CONTACT NOTICED THE PROBLEM WHEN HE PURCHASED THE VEHICLE, AND TOOK IT TO A LOCAL DEALERSHIP, WHO HAD THE ELECTRICAL SYSTEM REPLACED UNDER WARRANTY. THE DEALERSHIP STATED IT WAS BECAUSE OF THE PREVIOUS OWNER'S NEGLIGENCE. *AK
07/08/2005 · Fuel system
DT: THE CONSUMER EXPERIENCED AN ELECTRICAL PROBLEM, THERE IS A BUZZING NOISE COMING FROM THE FRONT OF VEHICLE, ONE OF THE WIRES COMING FROM THE BATTERY BECAME HOT, CAUSING IT TO MELT. THE FUEL PUMP DOES NOT WORK, CAUSING VEHICLE NOT START, VEHICLE SHUTS OFF AT HIGHER SPEEDS, CONSUMER TOOK VEHICLE TO DEALER, WHO TRIED TO FIX PROBLEM, BUT PROBLEM RECURRED.…
06/17/2005 · Electrical system
MOTORCYCLE HEADLIGHTS INTERMEITTENTLY TURN OFF. ELECTRICAL PROBLEM ALSO RESULTING IN MOTORCYCLE TURNING OFF DURING OPERATION. REFERE TO THIS WEB SITE FOR MANY DETAILS: HTTP://WWW.VFRDISCUSSION.COM/FORUM/INDEX.PHP?SHOWTOPIC=6856&HL=MY+FIRST+ELECTRICAL+PROBLEM
04/20/2005 · Electrical system
MOTORCYLE ENGINE WOULD TURN OVER, START, AND RUN STRONG, BUT WOULD DIE AFTER THE STARTER BUTTON WAS RELEASED. LOOKING OVER INTERNET DISCUSSION FORUMS THAT ARE DEDICATED TO THIS MODEL MOTORCYCLE, 2002-2005 HONDA VFR800, REVEALED A SUBSTANSIAL*AK NUMBER OF OWNERS EXPERIANCED THE SAME PROBLEM, MOST OF THE OWNERS ARE IN WET CLIMATES, EG., SEATTLE, PORTLAND, B…