2002 Honda Vfr800 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
What could happen: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
The fix: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 VFR800.
- Book a repair at any authorized Honda dealer. Quote NHTSA campaign 07V359000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-784-1870.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:WIRING
Summary: ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
Consequence: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY CONTACT HONDA AT 1-866-784-1870.
Notes: CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
What could happen: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
The fix: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 VFR800.
- Book a repair at any authorized Honda dealer. Quote NHTSA campaign 05V010000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC
Summary: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Consequence: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
Notes: HONDA RECALL NO. P65. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Portable jump starter
- 2002 Honda Vfr800 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (5), Unknown Or Other (1), Lights (1), Engine (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (6)
07/17/2008 · Unknown Or Other
TL*THE CONTACT OWNS A 2002 HONDA VFR800. THE CONTACT MAILED IN A WARRANTY CARD NOTIFYING THE HONDA MANUFACTURER THAT HE NOW OWNS THE MOTORCYCLE. THE WARRANTY INFORMATION WAS ENTERED INTO HONDA'S SYSTEM INCORRECTLY AND NOW IT STATES THAT THE MOTORCYCLE IS STOLEN. THERE IS A NHTSA CAMPAIGN ID NUMBER 07V359000 (ELECTRICAL SYSTEM:WIRING) ON THE VEHICLE, WHIC…
05/23/2007 · Electrical system
I OWN A 2002 HONDA VFR 800 MOTORCYCLE THAT HAS INCURRED ELECTRICAL PROBLEMS THAT 2 DEALERS WERE UNABLE TO REPAIR. THE ELECTRICAL PROBLEMS OCCURRED WHILE I WAS DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS, AND WHEN TRYING TO USE TURN SIGNALS. THE HEADLIGHTS WENT OUT AND THE ENGINE DIED...A VERY DANGEROUS SITUATION. NOW THE MOTORCYCLE STILL DID THE SAME…
10/03/2006 · Engine
MOTORCYCLE ENGINE DIED WHILE RUNNING. I DID TROUBLESHOOT TO FIND AN ELECTRICAL 30 AMP FUSE WIRE INSULATION SCORCHED AND BURNED THROUGH. COPPER CONDUCTOR HAD BECOME VERY HOT. *JB
09/11/2006 · Electrical system
HAD STARTING PROBLEMS AND WENT TO CHECK THE BATTERY. FOUND THAT THE FUSE HOLDER, A CONNECTOR AND THE SMALL WIRE BETWEEN THE TWO HAD DISCOLORED TO A BROWN. THERE WERE SIGNS OF MELTING ON THE WIRE INSULATION. THE PART HAS NOT FAILED TO DATE BUT GETS VERY HOT TO THE TOUCH WHEN THE VEHICLE ENGINE IS RUNNING. *JB
02/17/2006 · Electrical system
30AMP MAIN FUSE HOLDER MELTING. ENGINE STOPPED ON FREEWAY. *NM
07/25/2005 · Electrical system
DT: THE CONSUMER EXPERIENCED 4 SEPARATE ELECTRICAL FAILURES, IT HAS CAUSED HEADLIGHT AND ENGINE FAILURE. THE CONSUMER CONTACTED HONDA THEY HAVE REPAIRED THE ISSUE UNDER WARRANTY. THE GROUND WIRE HAS BURNED 3 TIMES AT DIFFERENT POINTS. THE 1ST TIME AUG 2002. FIRST TIME IT ONLY HAD 18,000 MILES. *JB