2016 Mitsubishi Outlander recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
8 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.
What could happen: If the engine stalls, there is an increased the risk of a crash.
The fix: MMNA will notify owners, and dealers will replace the affected relays, free of charge. The recall began October 24, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-005.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 17V609000 (manufacturer code SR-17-005).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2015-2017 Outlander, 2015-2016 Lancer and Outlander Sport, and 2015 Lancer Evolution vehicles. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.
Consequence: If the engine stalls, there is an increased the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the affected relays, free of charge. The recall began October 24, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-005.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind.
What could happen: If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.
The fix: MMNA will notify owners, and dealers will inspect the rear brake calipers and replace the parking brake boot and lever or the brake caliper body, as necessary. Dealers will also replace the piston assembly of the rear brake caliper. These repairs will be performed free of charge. The recall is expected to begin Mar…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 18V070000 (manufacturer code SR-18-002).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: PARKING BRAKE
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2016 Outlander and 2013-2016 Outlander Sport vehicles. Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind.
Consequence: If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the rear brake calipers and replace the parking brake boot and lever or the brake caliper body, as necessary. Dealers will also replace the piston assembly of the rear brake caliper. These repairs will be performed free of charge. The recall is expected to begin March 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-002.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Transmission / drivetrain
What's wrong, in plain English: The parts that send engine power to the wheels. Failure can mean a sudden loss of power or the car rolling away. The affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle accelerating.
What could happen: A hesitation during acceleration can increase the risk of a crash.
The fix: MMNA has notified owners, and dealers will reprogram the CVT control unit with modified software, free of charge. The recall began on August 15, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-006.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 16V563000 (manufacturer code SR-16-006).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2015-2016 Outlander Sport vehicles and 2016 Outlander and Lancer vehicles. The affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle accelerating.
Consequence: A hesitation during acceleration can increase the risk of a crash.
Remedy: MMNA has notified owners, and dealers will reprogram the CVT control unit with modified software, free of charge. The recall began on August 15, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-006.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. The second-row center seat belt buckle may interfere with the right-side seat belt buckle when the seat backs are folded down. The interference may cause the right-side seat belt buckle cover to come off, making the buckle latch inoperable and unable to restrain an occupant.
What could happen: An unrestrained occupant has an increased risk of injury in the event of a crash.
The fix: MMNA will notify owners, and dealers will modify the second-row center seat belt buckle cover, install a new warning label to the second-row seat support base, and provide a new warning label insert for the owner's manual, free of charge. The recall began September 1, 2020. Owners may contact MMNA customer service a…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 20V403000 (manufacturer code SR-20-004).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2019 Outlander and 2018-2019 Outlander PHEV vehicles. The second-row center seat belt buckle may interfere with the right-side seat belt buckle when the seat backs are folded down. The interference may cause the right-side seat belt buckle cover to come off, making the buckle latch inoperable and unable to restrain an occupant.
Consequence: An unrestrained occupant has an increased risk of injury in the event of a crash.
Remedy: MMNA will notify owners, and dealers will modify the second-row center seat belt buckle cover, install a new warning label to the second-row seat support base, and provide a new warning label insert for the owner's manual, free of charge. The recall began September 1, 2020. Owners may contact MMNA customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-20-004.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
5. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. The rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process. As a result, water entering the rear brake caliper boot may cause the parking brake operating shafts to corrode and possibly bind.
What could happen: If the parking brake operating shafts bind, the parking brakes may not engage or disengage fully. If the parking brakes do not engage properly, the vehicle could rollaway, increasing the risk of a crash.
The fix: MMNA will notify owners, and dealers will replace the rear brake caliper assemblies, free of charge. Owner letters were mailed May 4, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-005.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 20V741000 (manufacturer code SR-20-005).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: PARKING BRAKE
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process. As a result, water entering the rear brake caliper boot may cause the parking brake operating shafts to corrode and possibly bind.
Consequence: If the parking brake operating shafts bind, the parking brakes may not engage or disengage fully. If the parking brakes do not engage properly, the vehicle could rollaway, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the rear brake caliper assemblies, free of charge. Owner letters were mailed May 4, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-005.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
6. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles sold and/or currently registered in Alaska, Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, North Dakota, Nebraska, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, South…
What could happen: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
The fix: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed October 6, 2025. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-25-002
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 25V507000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles sold and/or currently registered in Alaska, Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, North Dakota, Nebraska, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, and Wisconsin.
The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.
Consequence: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
Remedy: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed October 6, 2025. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-25-002
Notes:
7. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.
What could happen: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
The fix: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed June 17, 2026. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-26-001. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on N…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 26V252000 (manufacturer code SR-26-001).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles. The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.
Consequence: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
Remedy: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed June 17, 2026. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-26-001. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov June 3, 2026. This recall expands previous NHTSA recall number 25V507.
Notes:
8. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. The inside door latch mechanisms may not latch securely in high temperatures, allowing the doors to open while vehicle is in motion.
What could happen: If a door opens while the vehicle is being driven, it can increase the risk of injury.
The fix: MMNA will notify owners, and dealers will replace the door latches, free of charge. The recall began August 25, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-002.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 17V233000 (manufacturer code SR-17-002).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The inside door latch mechanisms may not latch securely in high temperatures, allowing the doors to open while vehicle is in motion.
Consequence: If a door opens while the vehicle is being driven, it can increase the risk of injury.
Remedy: MMNA will notify owners, and dealers will replace the door latches, free of charge. The recall began August 25, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-002.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2016 Mitsubishi Outlander owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (71), Engine (29), Brakes (26), Unknown Or Other (19), Electrical system (17).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/15/2026 · Transmission / drivetrain
This vehicle exhibits a severe and dangerous acceleration hesitation, accompanied by a sudden, momentary loss of engine torque when pulling out from stops or trying to merge onto highways. This unexpected loss of power leaves the vehicle stranded briefly in oncoming traffic, creating an immediate crash hazard. This failure matches the exact physical defect…
09/05/2026 · Suspension
The annual state safety inspection failed due to a severely rust corroded front Cross-Member. A corrosion hole developed right where the air conditioner condensate drain port is located right above it. Earlier manufacturing years of this same vehicle had a major recall for this exact same cause. Continued use without replacing the front Cross-Member could…
08/27/2026 · Transmission / drivetrain
The contact owns a 2016 Mitsubishi Outlander. The contact stated that while driving 55 MPH and depressing the accelerator pedal, the vehicle unintendedly decreased speed. No warning lights illuminated. A dealer was contacted; however, the vehicle was not taken to a dealer to be diagnosed or repaired. The manufacturer was notified of the failure and informed…
07/23/2026 · Transmission / drivetrain
The car itself should not be sold considering the number of complaints about the transmission issues. I’ve only had the car a month and Its started to stall and jerks when in acceleration. The gears started to not shift properly and the car would not go over 20 miles without jerking. I took the car back to the lot to get it fixed and then it stopped, was dr…
02/17/2026 · Transmission / drivetrain
transmission went out
11/18/2025 · Brakes
The contact owns a 2016 Mitsubishi Outlander. The contact stated that upon manually activating the parking brake, the vehicle failed to respond as intended. The vehicle was taken to Jack's Independent Service Inc, where it was diagnosed and determined that the parking brake operating shafts were corroded. The dealer related the failure to NHTSA Campaign Num…
10/16/2025 · Transmission / drivetrain
The contact owns a 2016 Mitsubishi Outlander. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The contact stated that the failure occurred repeatedly after coming to a complete stop. The contact stated that because o…
09/23/2025 · Transmission / drivetrain
On the freeway TRANSMISSION FAILURE SERVICE light came on and the cars acceleration geared, had to immediately pull over on the side of the freeway, restarted the car with emergency lights to get out of the freeway. Vehicle would not accelerate much and the rpm was switching fast up and down. Check engine light came on the next day and the diagnosis read c…