1997 Toyota RAV4 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
What could happen: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 RAV4.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 09E012000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-909-598-7589.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1997 Toyota RAV4 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (14), Vehicle Speed Control (7), Body / structure (6), Transmission / drivetrain (6), Airbags (6).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/15/2019 · Electrical system
VEHICLE ALARM ADD ON MODULE AND HARNESS WERE FOUND TO BE FAULTY AND HAS SHORTED OUT UPON INSPECTION OF MODULE I HAVE FOUND BURNT CIRCUITS . VEHICLE IS UNABLE TO START ALSO LEADING TO BELIEVE THE ECM HAS BEEN EFFECTED .
02/19/2016 · Body / structure
1997 RAV4 AWD 109000 DEALER SERVICED TOOK IN FOR A OIL CHANGE 2/18/16 DEALER INFORMED ME THAT THE CRADLE ASSY HAS A TENNIS BALL SIZE HOLE IN IT NEAR NEXT TO LEFT CONTROL ARM , $2361.30 TO REPLACE OR JUNK THE VEHICLE NOT SAFE TO DRIVE, VEHICLE SERVICED EVERY 5000 MILES AND ITS BROUGHT TO MY ATTENTION NOW, MY 22 YR OLD DAUGHTER HAS BEEN DRIVING THIS VEHICLE T…
04/24/2015 · Engine
RECEIVED WARRANTY ENHANCEMENT NOTICE-ZE7, AS INSTRUCTED, DEALER TEST WAS PERFORMED. OIL LOSS TOTALS UNDER 1QT. FOR EA. 1200 MILES DRIVEN. WAS TOLD THIS DID NOT QUALIFY FOR REPAIR. MY CONCERN IS THIS: TOYOTA SERVICE REQUIRED FOR OIL CHANGE IS EVERY 5,000 MILES. MY CAR HAS EXCESSIVE OIL CONSUMPTION OF JUST UNDER 1QT PER 1,200 MILES, SO DRIVING 5,000 MILES WOU…
03/06/2015 · Transmission / drivetrain
RAV 4 TOYOTA 1997-WAS UNABLE TO DRIVE MORE THAN 30 MILES WITHOUT THE RPR INCREASED WITHOUT CONTROL, TRANSMISSION AND ENGINE BECOME EXTREMELY HOT, FLUIDS WERE DRAINED . CAR SENT TO DARCARS TOYOTA THERMOSTAT WAS REPLACED, AND NOW FACING SEVERE TRANSMISSION ISSUES, BECAUSE LACK OF RECALL RPR 'S ISSUE VERY DETRIMENTAL AND RISKY . *TR
07/04/2014 · Body / structure
MY SON WAS DRIVING, HIT A POTHOLE, AND THE SUB FRAME COMPLETELY BROKE IN HALF. UPON INSPECTION, I FOUND THAT IT HAD BEEN ROTTING OUT FROM THE TOP. *TR
12/03/2013 · Body / structure
WE TOOK OUR 1997 RAV4 TO THE MECHANIC FOR A ROUTINE TIRE ROTATION AND OIL CHANGE. THE MECHANIC INFORMED US THE SUBFRAME WAS SEVERELY RUSTED AND DANGEROUS TO DRIVE. I DID SOME RESEARCH ON THE PROBLEM AND FOUND OUT IT IS A COMMON OCCURRENCE WITH ALL RAV4'S AND THAT TOYOTA REFUSES TO ACCEPT RESPONSIBILITY FOR A MAJOR DESIGN FLAW IN THESE VEHICLES. I'VE NEVER H…
03/27/2012 · Body / structure
TL* THE CONTACT OWNS A 1997 TOYOTA RAV4. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE WHERE THEY DETECTED THAT THE ENTIRE SUBFRAME WAS COMPLETELY RUSTED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER FOR A SECOND OPINION. THE TECHNICIAN INFORMED THE CONTACT THAT THE BODY FRAME WOULD NEED TO BE REPLACED. TH…
03/21/2012 · Body / structure
THE SUB-FRAME IS RUSTING OUT AND I HAVE BEEN TOLD IT IS DANGEROUS TO DRIVE. TOYOTA HAS TOLD ME THERE IS NOTHING THEY CAN DO. *JS