1998 Toyota RAV4 recalls & complaints

Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
Remedy: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: SERVICE BRAKES, AIR:DISC:ROTOR
Summary: VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.
Consequence: THE DISC ROTOR COULD BREAK (WHERE IT MOUNTS TO THE WHEEL), RESULTING IN A LOSS OF BRAKING ACTION ON THAT WHEEL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DISC BRAKE ROTORS. IF THE VEHICLE IS EQUIPPED WITH STEEL WHEELS, TOYOTA WILL REPLACE THE FRONT DISC BRAKE ROTORS AND STEEL WHEELS WITH NEW DISC BRAKE ROTORS AND NEW ALUMINUM WHEELS. IN ADDITION A CAUTION LABEL THAT READS, "USE NEW GENUINE TOYOTA ALUMINUM WHEELS." WILL BE AFFIXED. VEHICLES ALREADY EQUIPPED WITH ALUMINUM WHEELS WILL ONLY REQUIRE CAUTION LABEL INSTALLATION.
Notes: ALL THESE VEHICLES ARE LEASED AND OPERATED IN FLEETS. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
Summary: VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. IF THE SUBJECT VEHICLES ARE REPEATEDLY PARKED BY PLACING THE SHIFT LEVER INTO THE "P" POSITION WITHOUT APPLYING THE PARKING BRAKE, THE PARKING LOCK ROD, A COMPONENT OF THE TRANSMISSION PARKING LOCK SYSTEM, COULD BREAK.
Consequence: THIS CONDITION CAN RENDER THE SYSTEM INOPERATIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING LOCK ROD.
Notes: ALL THESE VEHICLES ARE LEASED AND OPERATED IN FLEETS. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER/NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: EQUIPMENT DESCRIPTION: AFTERMARKET THEFT DETERRENT SYSTEMS USED ON 1998-1998 TOYOTA RAV4, AVALON, AND SIENNA MODEL VEHICLES DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN "OPEN CIRCUIT" CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS BEING HANDLED BY SOUTHEAST TOYOTA DISTRIBUTORS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

04/22/2021 · Fuel system
TL* THE CONTACT OWNS A 1998 TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE VAPOR CANISTER AND THE VACUUM SWITCHING VALVE (VSV) NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFA…

03/17/2021 · Airbags · crash
TL* THE CONTACT OWNED A 1998 TOYOTA RAV4. THE CONTACT STATED WHILE MAKING A LEFT TURN AT AN INTERSECTION, ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THEIR VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT TWO PEOPLE IN THE VEHICLE SUSTAINED INJURIES. THE PASSENGER IN THE PASSENGER SEAT SUSTAINED A BLACK…

11/16/2020 · Airbags
MY VEHICLE IS BEING RECALLED FOR TAKADA AIR BAGS.

02/24/2020 · Airbags
TL* THE CONTACT OWNS A 1998 RAV 4. THE CONTACT WAS NOTIFIED THROUGH LOCAL EMISSIONS THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V033000 (AIR BAGS). THE VIN TOOL CONFIRMS THAT THE VEHICLE WAS SUBJECTED TO THE RECALL. NEITHER A DEALER NOR THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS P…

10/30/2017 · Brakes
EVEN AFTER I REPLACED THE BRAKE PADS WHILE DOING MAINTENANCE, THE BRAKES ARE STILL LOOSE AT TIMES, MOSTLY AFTER RUNNING ON THE HIGHWAY.

03/24/2017 · Engine
EXCESSIVE OIL USE, TRIED TO HAVE DEALER FIX AT 149,000, WOULD NOT CHECK. WARENTY ENHANCEMENT, NOW 200000 MILES 1 QT+ 1200 MILES. TOOK TO DEALER 2/27/17 SAID I HAD TO PAY 3000+ TO FIX. TOYOTA NEW IT WAS BAD PISTONS OR RINGS AND ADMIT IT. BUT I PAY? ALWAYS TOOK CARE OF VEHICLE

04/07/2016 · Seat belts
RE: SAFETY RECALL FOR REAR OUTBOARD SEATBELTS. I FIRST BECAME AWARE OF THE THE RECALL IN FEB. 2016. IN EARLY MARCH, WE SCHEDULED NORMAL MAINTENANCE FOR OUR RAV4. WHEN WE INQUIRED ABOUT THE SEATBELT RECALL, THE DEALERSHIP HAD NO KNOWLEDGE OF THE ISSUE. I HAVE NOW BEEN DRIVING MY 6 AND 8 YEAR OLD CHILDREN AROUND IN A VEHICLE WITH RECALLED SEATBELTS FOR 2…

08/04/2014 · Brakes
TL* THE CONTACT OWNS A 1998 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE BRAKES WERE APPLIED AND THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE VEHICLE WAS DIFFICULT TO COME TO A STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FRONT DRIVER'S SIDE ROTOR WAS REPLACED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN ANY R…