2004 Winnebago Adventurer recalls & complaints

Component: EQUIPMENT
Summary: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
Consequence: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
Notes: WINNEBAGO RECALL NO. 93. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

Component: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Summary: CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.
Notes: WINNEBAGO RECALL NO. 92. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

07/24/2018 · Equipment
TL* THE CONTACT OWNS A 2004 WINNEBAGO ADVENTURER EQUIPPED WITH A NORCOLD REFRIGERATOR, MODEL NUMBER: 1201LRIM AND SERIAL NUMBER: 15374429. THE CONTACT STATED THAT THE REFRIGERATOR BEGAN LEAKING AND AN AMMONIA ODOR WAS DETECTED IN THE RECREATIONAL VEHICLE. THE NORCOLD MANUFACTURER WAS NOTIFIED AT 800 543-1219 AND INFORMED THE CONTACT THAT THE REFRIGERATOR WA…

10/28/2014 · Brakes
TL* THE CONTACT OWNS A 2004 WINNEBAGO ADVENTURER. THE CONTACT STATED THAT ALL FOUR ROTORS WERE DETERIORATED TO THE POINT OF POTENTIALLY FRACTURING. THE CONTACT MENTIONED THAT THE ROTORS WERE CRACKED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO AN AUTHORIZED DEALER. THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE WAS INCLU…

09/18/2013 · Fuel system
ON 09/13/13 I NOTICED AN ODOR OF GAS NEAR DRIVERS SIDE REAR TIRES. I SLID UNDER MOTORHOME AND NOTICED WET AREA ON GAS TANK. I INSPECTED THE GAS TANK AND FOUND GAS LEAKING FROM A SPOT WELD FOR THE INTERNAL BAFFLE IN THE GAS TANK. THIS IS A SERIOUS PROBLEM THAT COULD CAUSE A FIRE, GENERATOR IS CLOSE BY. LEAK COULD ALSO BE IGNITED FROM A SPARK FROM A CAMPFIR…

04/20/2011 · Fuel system
TL* THE CONTACT OWNS A 2004 WINNEBAGO ADVENTURER RV. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED FUEL LEAKING FROM THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THERE WAS A HOLE WITHIN AN INTERNAL WELD ON THE FUEL TANK. THE FUEL TANK WAS REPLACED. APPROXIMATELY THREE YEARS LATER, THE FAILURE RECURRED. THE V…

02/08/2011 · Engine
I OWN A 2004 WINNEBAGO ADVENTURER WPG38R. I INCURRED WHAT AMOUNTED TO A PREMATURE FAILURE OF THE EXHAUST SYSTEM ON MY ON A GENERATOR, DIRECTLY CAUSED BY WINNEBAGO IGNORING ONAN'S "RECOMMENDED" INSTALLATION INSTRUCTIONS. THOSE INSTRUCTIONS SPECIFICALLY STATE A SUPPORT BRACKET BE INSTALLED IF THE TAILPIPE ASSEMBLY IS MORE THAN 18" LONG. THE TAILPIPE ASSEM…

11/30/2010 · Brakes
WORKHORSE CUSTOM CHASSIS SAFETY RECALL 51101-C, REPLACEMENT OF BOSCH SERVICE BRAKE CALIPERS. DEALER INTENTIONALLY FAILED TO HAVE CALIPERS REPLACED PRIOR TO SALE OF VEHICLE. PURCHASER OF VEHICLE COMPLAINED TO DEALER THAT TIRES WERE BAD AND, AFTER REMOVING TIRES, THAT BRAKE PADS, CALIPERS AND ROTORS WERE ALSO BAD. DEALER REFUSED TO REMEDY ANY OF THE COMPL…

09/17/2010 · Brakes · crash
THERE HAVE BEEN REPEATED ATTEMPTS TO REPAIR THE ABS SYSTEM ON MY CLASS A MOTORHOME,SINCE THE TIME OF PURCHASE, INCLUDING 1 MANUFACTURER RECALL ON THE ABS SYSTEM AND 2 RECALLS ON THE HYDRAULIC BRAKES. I HAVE COMPLETED ALL OF THE RECALL ORDERS AND ALSO HAD INTERMITTENT INSPECTIONS ON THE BRAKES. THIS MORNING I HAD AN ACCIDENT DUE TO A BRAKE FAILURE. THE B…

11/03/2009 · Brakes
THIS IS IN REFERENCE TO SAFETY RECALL 50901-C AN INTERIM NOTICE FROM WORKHORSE CUSTOM CHASSIS. MY MOTORHOME IS INVOLVED IN THIS RECALL. I EXPERIENCED BRAKE PROBLEM (OVER HEATING) RETURNING FROM A TRIP TO VIRGINIA IN SEPTEMBER 2009. I WAS ABLE TO GET HOME WITHOUT MAJOR PROBLEMS. THE MOTORHOME WAS REPAIRED WITH LIKE PARKS (SUBJECT TO FAILURE) PAID FOR BY WO…