2004 Winnebago Minnie recalls & complaints

1. Equipment

What's wrong, in plain English: A part or accessory supplied with the vehicle. ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

What could happen: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

The fix: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE…

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MINNIE.
2. Book a repair at any authorized Winnebago dealer. Quote NHTSA campaign 03V405000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

2. Electrical system

What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.

What could happen: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.

The fix: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MINNIE.
2. Book a repair at any authorized Winnebago dealer. Quote NHTSA campaign 04V512000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Manufacturer hotline: 1-800-392-3673.
5. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

3. Engine

What's wrong, in plain English: Engine problems range from stalling to fire. ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

What could happen: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

The fix: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MINNIE.
2. Book a repair at any authorized Winnebago dealer. Quote NHTSA campaign 04V516000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Manufacturer hotline: 1-800-392-3673.
5. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

4. Fuel system

What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.

What could happen: IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.

The fix: DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MINNIE.
2. Book a repair at any authorized Winnebago dealer. Quote NHTSA campaign 05V475000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

5. Electrical system

What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT OVERHEAD TELEVISIONS, INCORRECT FASTENERS WERE USED TO SECURE THE TELEVISION LOCATED IN THE FRONT OVERHEAD AREA OF THE MOTOR HOME.

What could happen: THE TELEVISION MAY BECOME LOOSE AND POSSIBLY FALL FROM ITS POSITION WHICH HAS THE POTENTIAL TO IMPACT THE DRIVER OR PASSENGERS, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

The fix: DEALERS WILL INSPECT THE VEHICLE TO ASSURE THE CORRECT FASTENERS (BOLTS) WERE USED IN THE TV RETENTION STRAP. THE RECALL BEGAN ON DECEMBER 15, 2006. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

What to do

1. Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MINNIE.
2. Book a repair at any authorized Winnebago dealer. Quote NHTSA campaign 06V456000.
3. The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
4. Manufacturer hotline: 1-800-537-1885.
5. Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.

Owner complaints filed with NHTSA

Most complained-about parts: Equipment (2), Wheels / tires (1).

Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.