2004 BMW 1 Series recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Steering (1), Suspension (1), Engine (1), Fuel system (1), Visibility (wipers / glass) (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (3)
01/11/2018 · Steering
THE '04 BWM 545I HAS BEEN LEAKING MOTOR OIL THROUGHOUT THE MOTOR GASKET AND HOLES. THE POWER STEERING IS LEAKING HOLES CONNECTING TO THE TRANSMISSION IS LEAKING AND THE RESERVOIR STAYS LOW ON FUILD DUE TO THE ISSUE I HAD TO PARK THE CAR IN GARAGE, IS CURRENTLY NOT BEING USED BECAUSE ALL OF THESE ISSUES NOT DRIVEABLE
06/03/2016 · Fuel system
GAS TANK IS NOT REGISTERING PROPERLY. GAUGE SHOWS NEEDING FUEL BUT GAS COMES OUT WHEN YOU ARE PUMPING SIGNIFYING THAT IT IS FULL. ALSO, PUMP TO WINDSHIELD WIPER FLUID IS NOT WORKING. DEALER REFUSED TO FIX.
06/06/2014 · Airbags
TL* THE CONTACT OWNS A 2004 BMW 5301. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE DEALER RESET THE AIR BAG SYSTEM HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 08V384000 (AIR BAGS). THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE CURRENT MI…