1996 Chevrolet Explorer recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (2), Hydraulic (2), Vehicle Speed Control (2), Wheels / tires (1), Visibility (wipers / glass) (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (7)
05/06/2003 · Brakes
WHILE DRIVING, THE ABS ENGAGED WITHOUT CAUSE. *JB
08/23/2001 · Vehicle Speed Control
WHILE TRAVELING AT 35 MPH VEHICLE ACCELERATED SUDDENLY AND WITHOUT WARNING. DRIVER HAD TO APPLY EMERGENCY PARKING BRAKE, AND TURN VEHICLE OFF TO STOP. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION.*AK
03/22/2001 · Brakes
CONSUMER TOOK VEHICLE IN FOR INSPECTION. BRAKES WERE WARPED AFTER SLAMMING ON BRAKES. CONSUMER NOTICED THAT AT HIGH SPEED BRAKING TO SLOW DOWN VEHICLE WOBBLED. CONSUMER TOOK VEHICLE IN TO BE CHECKED, BUT DEALER SAID IT AFFECTED SAFETY OF VEHICLE.*AK
08/07/2000 · Wheels / tires · crash
THE OWNER OF THE VEHICLE WAS TRAVELING IN THE LEFT LANE ON I-85 JUST NORTH OF ATLANTA. THE SPEED OF THE VEHICLE WAS 70 MPH. THE LEFT REAR TIRE OF THE VEHICLE MADE A NOISE THAT SOUNDED LIKE THE TREAD CAME OFF OF IT. THE TIRE BLEW A FEW SECONDS LATER. THIS CAUSED THE VEHICLE TO LOSE CONTROL. THE VEHICLE TRAVELED FROM THE LEFT LANE TO THE GUARD RAIL WHICH…
03/16/2000 · Vehicle Speed Control
THE ACCELERATOR PEDAL STUCK TO THE FLOOR WHILE DRIVING BECAUSE THE CRUISE CONTROL CABLE CLIP FELL OFF AND INTANGLED WITH THE ACCELERATOR CAUSING THE VAN TO TAKE OFF OUT OF CONTROL. YH
10/22/1997 · Visibility (wipers / glass)
POWER WINDOW MOTOR FAILED.
08/28/1997 · Engine
ENGINE FAILED.