1994 Ford F-350 recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING
Summary: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: TIRES:TREAD/BELT
Summary: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Consequence: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Notes:

Component: SEATS
Summary: THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.
Consequence: CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.
Notes: SYSTEM: INTERIOR; TRACKS AND ANCHORS; FRONT SEAT; LUMBAR SYSTEM. VEHICLE DESCRIPTION: SUPER CAB PICKUP TRUCKS EQUIPPED WITH AN OPTIONAL40/20/40 POWER FRONT DRIVER SEAT. NOTE: OWNER NOTIFICATION SHOULD BEGIN DURING THE LAST WEEK OF MAY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: STRUCTURE:BODY:BUMPERS
Summary: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
Notes: SYSTEM: STRUCTURE; BUMPER ASSEMBLY. VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTIPURPOSE VEHICLES. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT FORD SERVICE CENTER AT 1-800-392-3673. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: PARKING BRAKE:CONVENTIONAL
Summary: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
Notes: SYSTEM: EMERGENCY PARKING BRAKE; MECHANICAL. VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTIPURPOSE VEHICLES WITH MANUAL TRANSMISSIONS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLETIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT FORD AT 1-800-392-3673. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: ELECTRICAL SYSTEM:IGNITION:MODULE
Summary: IN A HEAVILY LOADED VEHICLE, WHILE IN THE CRUISE CONTROL MODE, THE THROTTLE MAY NOT REDUCE IMMEDIATELY WHEN THE LOAD ON THE ENGINE IS DECREASED (SUCH AS WHEN THE VEHICLE CRESTS A HILL.) THIS CAN RESULT IN INCREASED VEHICLE SPEED WITHOUT PRIOR WARNING.
Consequence: THIS CAN RESULT IN LOSS OF SPEED CONTROL OF THE VEHICLE, AND A POSSIBLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE ELECTRONIC ENGINE CONTROL MODULE.
Notes: SYSTEM: ELECTRICAL SYSTEMS; IGNITION; ELECTRONIC ENGINE CONTROL MODULE THAT INCLUDES THE CRUISE CONTROL FUNCTION. VEHICLE DESCRIPTION: PICKUP TRUCKS AND CHASSIS-CABS EQUIPPED WITH DIRECT INJECTION TURBO DIESEL ENGINES AND A FIVE-SPEED MANUAL TRANSMISSION, AND OVER 8,500 LBS. GROSS VEHICLE RATING. NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT FORD AT1-800-392-3673. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

11/17/2023 · Vehicle Speed Control
The contact owns a 1994 Ford F-350. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not…

05/15/2015 · Wheels / tires
IN MARCH OF 2014 I PURCHASED A SET OF TIRES FROM TREADWRIGHT TIRES WITHIN A VERY SHORT TIME I NOTICED THE SIDE WALLS CRACKING , BEFORE I COULD GET ANY RESPONSE I HAD A BLOW OUT ON MY RIGHT FROM TIRE AT 60 MPH, I WENT THROUGH TWO MORE SETS WITH THE SAME RESULTS OF SIDE WALL CRACKING BUT NO BLOW OUTS I AM NOW ON MY FOURTH SET , THEY ARE A DIFFERENT MODEL TIRE…

11/28/2008 · Vehicle Speed Control · fire
F350 FORD SUPERCREW 4X4 7.3 TURBO DIESEL HAD BEEN SITTING FOR 4 DAYS. WIFE COMES OUT OF HOUSE FINDS TRUCK ON FIRE IN ENGINE COMPARTMENT ON DRIVER'S SIDE. THE CRUISE DEACTIVATION SWITCH WAS DISCONNECTED. *TR

09/06/2007 · Transmission / drivetrain
TL*THE CONTACT OWNS A 1994 F-350. WHILE DRIVING 20 MPH, ALL OF THE SENSORS FAILED AND DAMAGED THE TRANSMISSION. THE CONTACT STATED THAT THE SENSOR LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL TO WARN HER OF THE FAILURE. THE SENSORS AND THE TRANSMISSION WERE REPLACED BY A LOCAL MECHANIC. THE DEALER INFORMATION WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES…

09/21/2006 · Vehicle Speed Control · fire
1994 FORD F-350 HAD AN UNDER HOOD FIRE. *KB A RECALL WAS RECEIVED IN REFERNCE TO FAULTY SPEED CONTROL DEACTIVATION SWITCH FOR THE CONSUMER'S 1995 F-250 BUT NOT THE 1994 F-350. *NM

07/10/2005 · Electrical system · fire
OUR 1994 FORD F-350 WAS DESTROYED BY FIRE ORIGINATING AT THE MASTER CYLINDER TODAY. THERE WAS A SMALL BRAKE FLUID LEAK NOTICED IN THIS AREA THE OTHER DAY; BUT I WAS UNAWARE OF THE CRUISE CONTROL SHUTOFF SWITCH DANGER UNTIL AFTER THE FIRE. I HAVE RECEIVED NO NOTICE OF A RECALL FOR THIS VEHICLE.

03/30/2005 · Brakes
BRAKE FADE. WHEN AT A COMPLETE STOP, PEDAL WILL SINK SLOWLY BUT NOT ENOUGH TO ACTIVE A WARNING LIGHT. IF PEDAL IS NOT PRESSED HARDER VEHICLE WILL ROLL. DEALERSHIP SAYS THIS IS NOT THE FIRST VEHICLE TO DO THIS AND HAS CONTACTED THE MANUFACTURER. VEHICLE STILL DOES IT TO THIS DAY. MASTER CYLINDER HAS BEEN REPLACED TWICE, STILL NOT FIXED.*AK

03/17/2005 · Vehicle Speed Control · fire
WHEN ATTEMPTING TO START THE VEHICLE SMOKE CAME FROM THE ENGINE COMPARTMENT. CONSUMER IMMEDIATELY GOT OUT AND DISCONNECTED THE CRUISE CONTROL CABLE WIRES. THEN, THE SMOKE STOPPED. *AK