2002 Ford F-650 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. CERTAIN MEDIUM DUTY PICKUP TRUCKS EQUIPPED WITH AIR BRAKES THAT INCLUDE THE OPTIONAL TRAILER PACKAGE FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE LINES CONNECTED TO THE TRACTOR PROTECTION VALVE ARE MISROUTED.
What could happen: A LEAK IN THE PRIMARY AIR CIRCUIT OR SECONDARY AIR CIRCUIT COULD RESULT IN A REDUCTION OR LOSS OF THE TRAILER BRAKE EFFECTIVENESS, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL RE-ROUTE THE AIR LINES CONNECTED TO THE TRACTOR PROTECTION VALVE. OWNER NOTIFICATION BEGAN JANUARY 31, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 F-650.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 02V024000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-248-0186.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Summary: CERTAIN MEDIUM DUTY PICKUP TRUCKS EQUIPPED WITH AIR BRAKES THAT INCLUDE THE OPTIONAL TRAILER PACKAGE FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE LINES CONNECTED TO THE TRACTOR PROTECTION VALVE ARE MISROUTED.
Consequence: A LEAK IN THE PRIMARY AIR CIRCUIT OR SECONDARY AIR CIRCUIT COULD RESULT IN A REDUCTION OR LOSS OF THE TRAILER BRAKE EFFECTIVENESS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-ROUTE THE AIR LINES CONNECTED TO THE TRACTOR PROTECTION VALVE. OWNER NOTIFICATION BEGAN JANUARY 31, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Lights (2), Brakes (2), Transmission / drivetrain (2), Electrical system (1), Hydraulic (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (3)
11/12/2015 · Electrical system
WHEN IT RAINS OUT IT MAY START ON ITS OWN TURN LIGHTS ON SITTING IN THE DRIVEWAY IN THE MIDDLE OF THE NIGHT WAS THE FIRST TIME IT ALWAYS STARTS WHILE SITTING TOLD THERE WAS A PROBLEM WITH WATER GETTING IN GEM MODUEL.
10/01/2003 · Brakes
THE HYDRAULIC UNIT SLAVE CYLINDER WHEN PUSHING INTO THE CLUTCH DISENGAGED, WHICH CAUSED THE VEHICLE TO ACCELERATE SIMULTANEOUSLY. *AK FLUID LEAKED OUT OF THE MASTER CYLINDER AND WAS REMOVED AND REPLACED. *SCC ALSO THE TAIL LIGHT WAS REPLACED *JB
07/07/2003 · Transmission / drivetrain
CLUTCH PEDAL STUCK AT FLOOR. @ 3,548 MILES ON TRUCK. INSTALLED DRIVE LINE AND ORDERED CLUTCH PEDAL SPRING (108T REPLACED CLUTCH MASTER ASSM AND RECALL SPG. ADJ. CLUTCH). 33,071 MILES NOTE ON OIL CHANGE INVOICE CLUTCH RETURN SPRING AT TRANS BROKE NEED REPAIR ASAP ALSO U-JOINT CLIP OFF NEED REPAIR, RELEASED BY RON MCMILLON. CLUTCH PEDAL STUCK TO FLOOR AT 43,9…